Filter
Top Products
________________________________
_______________________________
_______________________________
________________________________
________________________________
________________________________
_______________________________
_______________________________
_______________________________
_______________________________
_______________________________
________________________________
________________________________
_______________________________
_______________________________
_______________________________
_______________________________
Date: ________________
A, B, C, and D – Service Required
Change Rear Axle OIl (4WD)
A, B, and C – Service Required
(See Operator’s and Service Manual for specifications and procedures.)
Groundsmaster
R
Unit Designation:
Hours:
__________________–__________________
Service to perform (circle):
A B C D E Other
Remarks:
A– Service (every 50 hours) B – Service (every 100 hours) C – Service (every 200 hours)
D – Service (every 400 hours)
E – Service (every 600 hours)
Check Battery Level/Cable Connections
Check Cutting Unit Gearbox Oil Level
Clean Under Cutting Unit Belt Covers
Change Engine Oil and Filter
Inspect Cooling System Hoses
A–Level Service Required
Change Fuel Filter
Inspect Fuel Lines and Connections
(Duplicate this page for routine use.)
Change Cutting Unit Gearbox Oil
Replace Moving Hoses
Replace Safety Switches
Cooling System Flush/Replace Fluid
Hyd. Oil (see note on Maint. Sched.)
Hyd. Filter (see note on Maint. Sched.)
Groundsmaster 3000/3000–D
Page 2 – 16
Product Records and Maintenance
Rev. A
3000–D Supervisor Maintenance Work Order
Technician:
TORO I.D. #:
Lubricate All Grease Fittings
Inspect Air Filter
Check Cutting Unit Drive Belt Adjustment
Check Fan and Alternator Belt Tension
Service Air Filter
Check Rear Axle OIl Level (4WD)
Torque Wheel Lug Nuts
A and B – Service Required
Check Engine RPM (Idle & Full Throttle)
Inspect Timing Belt
Drain and Clean Fuel Tank
Pack 2WD Rear Axle Bearings
Check Rear Wheel Toe–In
Other – Annual Service & Specials
Timing Belt (see note on Maint. Sched.)