Filter
Top Products
S205 Skid-Steer Loader
Operation & Maintenance Manual 76
HEATING AND AIR CONDITIONING
Cleaning and Maintenance
The heater and air conditioning system require regular
inspection and maintenance. See your SERVICE
SCHEDULE for intervals. (See SERVICE SCHEDULE on
Page 65.)
Filters
Figure 133
The Fresh Air Filter is located below the rear window of
the cab (1) [Figure 133].
Remove the bolts and remove the filter housing.
Shake the filter or use low air pressure to remove dirt.
Replace after cleaning three times or if filter becomes too
dirty to clean.
Reinstall the filter, housing and bolts.
The Recirculation Filter is located in front of the rear
window inside the cab (2) [Figure 133].
Remove the clamping knobs, grill and filter.
Clean the filter with water and mild detergent. Reinstall
the filter. Replace after cleaning three times, or if filter
becomes too dirty to clean.
Evaporator
Figure 134
Raise the cab and remove the evaporator cover (1)
[Figure 134].
Use low pressure water or air to remove debris from the
evaporator fins.
Install the cover.
Air Conditioning Lubrication
Run the air conditioner for about 5 minutes every week to
lubricate the internal components. (In winter too.)
Troubleshooting
If the fan does not run, or the air conditioning does not
turn on, Check the fuse. (See ELECTRICAL SYSTEM on
Page 84).
If the air conditioning system circulates warm air, the
refrigerant may need to be recharged.
P-48012
2
1
P19427
1