Filter
Top Products
Safety Section 1-8
SR15 10-01
SAFETY
© 2004 Alamo Group Inc.
SAFETY
WARNING!
Many varied objects, such as wire, cable, rope, or chains, can become
entangled in the operating parts of the mower head. These items could
then swing outside the housing at greater velocities than the blades.
Such a situation is extremely hazardous and could result in serious
injury or even death. Inspect the cutting area for such objects before
mowing. Remove any like object from the site. Never allow the cutting
blades to contact such items. (SGM-6)
WARNING!
Mow at the speed that you can safely operate and control the tractor and
mower. Safe mowing speed depends on terrain condition and grass
type, density, and height of cut. Normal ground speed range is from 0
to 5 mph. Use slow mowing speeds when operating on or near steep
slopes, ditches, drop-offs, overhead obstructions, power lines, or when
debris and foreign objects are to be avoided. (SGM-7)
WARNING!
Extreme care should be taken when operating near loose objects
such as gravel, rocks, wire, and other debris. Inspect the area before
mowing. Foreign objects should be removed from the site to prevent
machine damage and/or bodily injury or even death. Any objects
that cannot be removed must be clearly marked and carefully
avoided by the operator. Stop mowing immediately if blades strike
a foreign object. Repair all damage and make certain rotor or blade
carrier is balanced before resuming mowing.
(SGM-5)
WARNING!
Avoid mowing in reverse direction when possible. Check to make sure
there are no persons behind the mower and use extreme care when
mowing in reverse. Mow only at a slow ground speed where you can
safely operate and control the tractor and mower. Never mow an area
that you have not inspected and removed debris or foreign material. (SGM-
8)
WARNING!
Do not put hands or feet under mower decks. Blade Contact can result
serious injury or even death. Stay away until all motion has stopped
and the decks are securely blocked up. (SGM-9)
DANGER!
Replace bent or broken blade with new blades. NEVER ATTEMPT
TO STRAIGHTEN OR WELD ON BLADES SINCE THIS WILL
LIKELY CRACK OR OTHERWISE DAMAGE THE BLADE WITH
SUBSEQUENT FAILURE AND POSSIBLE SERIOUS INJURY FROM
THROWN BLADES. (SGM-10)
WARNING!
Do not mow with two machines in the same area except with Cab tractors
with the windows closed. (SGM-11)
Follow these guidelines to reduce the risk of equipment and grass fires
while operating, servicing, and repairing the Mower and Tractor:
-Equip the Tractor with a fire extinguisher in an accesible location.
-Do Not operate the Mower on a Tractor with an underframe exhaust.
-Do Not smoke or have an open flame near the Mower and Tractor.
-Do Not drive into burning debris or freshly burnt areas.
-Ensure slip clutches are properly adjusted to prevent excessive slippage
and plate heating.
-Never allow clippings or debris to collect near drivelines, slip clutches,
and gearboxes. Periodically shut down the Tractor and Mower and clean
clippings and collected debris from the mower deck. (SGM-12)
WARNING!