Filter
Top Products
PAGE 40 — DCA70SSJU4i
or Every
or Every
OTHER
Engine
Check Engine Oil and Coolant Levels X
Check Fuel Filter/Water Separator Bowl X
Check Air Cleaner X
Check Air Cleaner Element X
Check for Leaks/Hoses/Clamps X
Check for Loosening of Parts X
Change Engine Oil and Oil Filter *
1
X
Clean Unit, Inside and Outside X
Replace Fuel Filter Elements X
Check Engine Mounts X
Service Battery X
Check Air Intake Hoses X
Check Fan Belt Condition X
Check Automatic Belt Tensioner X
Check Electrical Ground Connection X
Clean Radiator, Check Cooling System X
Coolant Solution Analysis, Add SCA's As Required X
Pressure Test Cooling System X
Check Engine Speed X
Test Thermostats X
Check and Adjust Engine Valve Clearance X
Test Glow Plugs X
Inspect Diesel Particulate Filter (DPF) *
2
X
Flush and Refill Cooling System*
3
2 yrs. or 2000 hrs.
Clean Inside of Fuel Tank 1000 hrs.
Check Crankcase Ventilation Filter*
4
1500 hrs.
Replace Air Cleaner Elements *
5
As Required
Generator
Measure Insulation Resistance Over 3M ohms X
Check Rotor Rear Support Bearing X
*
1
During initial operation of a new engine, change oil and filter between a minimum of 100 hrs. and a maximum of 250 hrs. Service interval depends
on type of oil.
*
2
Expectation for minimal service interval will be at least 3000 hrs. based on engine power. However, actual service should take place when
indicated by diagnostic gauge. Please contact nearest authorized Multiquip Service Center for DPF Cleaning.
*
3
If John Deere COOL-GARD™ John Deere COOL-GARD™ II is used, the flushing intervals may be extended. See "Testing Diesel Coolant" in
engine manual.
*
4
Minimal Service interval will be at least 1500 hrs. or when service indicator light turns on or as indicated by diagnostic guage. Critical emission
related service requred before 1500 hrs. is not necessary. The emissions-related warranty is valid up to 1500 hrs.
*
5
Replace primary air filter element when restriction indicator shows a vacuum of 625 mm (25 in. H
2
0).
MAINTENANCE