Agri-Fab 45-04072 Yard Vacuum User Manual


  Open as PDF
of 28
 
18
MAINTENANCE
Service Dates
Checkforloosefasteners X
 Checkcover X
 Checktirepressure X
 Checkengineoillevel X
Lubricate X
Clean X X
Maintain engine per instructions below and in engine manual.
Beforeeachuse
After each use
Every season
Beforestorage
CUSTOMER RESPONSIBILITIES
• Readandfollowthemaintenancescheduleandthemaintenanceprocedureslistedinthissection.
MAINTENANCE SCHEDULE
Fill in dates as you
complete regular service.
BEFORE EACH USE
CHECK FOR LOOSE FASTENERS
• MakeathoroughvisualcheckoftheVacSystemforany
bolts and nuts which may have loosened. Retighten any
loose bolts and nuts.
CHECK COVER
• Checkthecover,especiallythefrontbootandtherear
apforwear.Replacecoverifwornordamaged.
CHECK TIRE PRESSURE
• Check tire pressure regularly. Recommended tire
pressure is printed on tire.
CHECK ENGINE OIL LEVEL
• Checkoillevelbeforeeachuse.Maintainengineoilas
instructed in the separate engine manual.
LUBRICATION
• At the beginning of each season, lubricate the latch,
latch pivot bolt, and the axle where the hitch tongue
pivots, with a light machine oil.
• Atleastonceaseason,greaseoroilthewheelbearings.
Use automotive wheel bearing type grease or 20 weight
oil.
WARNING: Always stop engine and
disconnectspark plugwire beforecleaning,
lubricating or before performing any repairs
or maintenance.
ENGINE MAINTENANCE
Only use high quality detergent oil rated with API service
classicationSForSG.Selecttheoil'sSAEviscositygrade
according to your expected operating temperature. SAE 30
grade oil is recommended for warm weather use. For cold
weather use refer to the engine manufacturer's Operating
and Maintenance Manual.
• Checkoil level before each use. Maintain engine oil as
instructed in the separate engine manual.
• Service air cleaner every 25 hours under normal
conditions. Clean every few hours under extremely
dustyconditions.Poorengineperformanceandooding
usually indicates that the air cleaner should be serviced.
To service the air cleaner, refer to the separate engine
manual.
• Thespark plug should be cleaned and the gap reset
onceaseason.Sparkplugreplacementatthestartof
eachseasonisrecommended.Checktheenginemanual
forcorrectplugtypeandgapspecications.
CLEANING
• Makesurethecartandtoparecleanedaftereachuse.
Grass clippings and leaves left in the cart will mildew
and cause damage if not cleaned out.
• Clean the engineregularlywithaclothorbrush.Keep
thecoolingnsontheenginehousingcleantopermit
proper air circulation which is essential to engine
performance andlife.Be suretoremoveall dirtand
debrisfrommuferarea.
 previous next