Filter
Top Products
16-2
16. STORAGE
Ex2900 / 3200 Operator's Manual
2. Preparing the Fuel and Engine for Storage
■ Fuel
If using stabilized fuel, fully fill the fuel tank with stabilized fuel.
NOTE:
●By filling the fuel tank, the amount of air remaining in the tank decreases,
and this can help prevent deterioration of the fuel in the tank.
If stabilized fuel has not been used.
1. Park the tractor safely in a well-ventilated place.
NOTE:
●Assuming that this is the last time the tractor is operated for the season,
use all the fuel in the fuel tank.
2. Run the engine until all the fuel in the tank is used.
3. Turn the starter key switch to the OFF position.
IMPORTANT: Be very careful to avoid damage.
●In degraded fuel, varnish can occur and clog the fuel injector components
and adversely affect engine performance.
●Mix stabilizer into fresh fuel before filling the fuel tank.
4. Mix fresh fuel and fuel stabilizer in a separate container.
Observe the stabilizer manufacturer's instructions for mixing.
5. Fill the fuel tank with the stabilized fuel.
6. Run the engine for several minutes to allow the fuel-stabilizer mixture to
be circulated through the fuel system.
■ Engine
If the tractor is scheduled to be stored for longer than 60 days, prepare the
engine for storage.
1. Change the engine oil and filter while the engine is still warm.
2. Service the air filter if necessary.
3. Remove dust and debris from the engine air intake screen.
4. Clean the engine and engine compartment.
IMPORTANT: Avoid damage.
●ALWAYS disengage the clutch before storing the tractor. If the clutch is
engaged for a long period, the clutch plate may develop rust, causing the
clutch to not disengage when the tractor is operated next time.
5. Remove the battery.
6. Clean the battery and battery posts. Check the electrolyte level.
7. Close the fuel shut-off valve.
8. Store the battery in a cool, dry, dark place. However, the temperature of
that place must not become low enough to freeze the electrolyte in
battery.
9. Store the tractor in a dry, safe place. If the tractor is stored outdoors,
protect it with a waterproof cover. Jack up the tractor and place blocks
under the front and rear axles to allow the tires to be lifted off the
ground. Do not allow the tires to be exposed to direct sunlight or
extremely high temperature.