Filter
Top Products
IV. SERVICE
1. Use extra care in handling gasoline and other fuels. They are
flammable and vapors areexplosive.
a. Useonly an approved container.
b. Never remove gas cap or add fuel with the engine running.
Allow engine to cool at least two minutes before refueling.
Do not smoke.
c. Never refuel the machine indoors.
d. Never store the machine or fuel container inside where
there is an open flame, or spark, such as a water heater,
space heater,clothes dryer and the like.
2. Never runa machine inside a closed area.
3. Check frequently and keep nuts and bolts, especially blade
attachment bolts, tight and keep equipment in safe working
condition.
4. Nevertamper with safety devices. Checktheir proper operation
regularly. Use all guards asinstructed in this manual.
5. To reduce fire hazard, keep machine free of grass, leaves or
other debris build-up. Clean up oil or fuel spillage. Allow
machine to cool before storing.
6. Stop and inspect the equipment for damage if you strike an
object. Repair, if necessary, before re-starting and operating
the machine.
7. Nevermakeadjustments or repairs with the engine running.
8. Grass catcher components are subject to wear, damage and
deteriorate, which could expose moving parts or allow objects
to be thrown. Frequently, check components and replace with
manufacturer's recommended parts when necessary.
9. Mower blades are sharp and can cut. Wrap the blade(s) or
wear gloves and useextra caution when servicing blade(s).
10. Check brake operation frequently. Adjust and service as
required.
11. Muffler, engine, and belt guards become hot during operation
and can causea burn. Allow to cool down before touching.
12. Do not change the engine governor settings or overspeed the
engine.
,_ Yourunitwasbuilttobe operatedaccordingtotherulesforsafeoperationinthismanual.Aswithanytype
DANGER: of powerequipment,carelessnessorerroronthepartoftheoperatorcanresultinseriousinjury,if youvio-
lateanyoftheserules,youmaycauseseriousinjurytoyourselforothers.
ASSEMBLY INSTRUCTIONS
IMPORTANT: After assembly, service engine with
gasoline, and check oil level as instructed in the
separate engine manual packed with your unit.
NOTE: Reference to right or left hand side of the
unit is observed from the driver's seat, facing for-
ward.
Self-Tapping Screws
FIGURE 1.
I
WARNING
UNPACKING
1. Remove the lawn tractor from the carton as fol-
lows. Open the top flaps. The loose parts (include
the battery fluid, steering wheel with steering cap
attached and chute deflector) are on the seat and
wrapped in plastic. Remove all carton inserts. Cut
the front corners of the carton. Make certain
brake is released, and push the unit out of the
carton.
2. The seat has been mounted backward for ship-
ping purposes. Carefully cut and remove the plas-
tic wrap. Remove the loose parts from the seat.
--I--ASSEMBLING THE SEAT
Remove the hex self-tapping screws which secure the
seat to the seat pivot bracket. Turn the seat around
and place in position against the seat pivot bracket,
lining up the slotted holes in the pivot bracket with the
holes in the seat. Select desired position for the seat,
and secure with hex self-tapping screws. See figure 1.
BATTERYINFORMATION
A. Battery acid must be handled with great care as
contact with it can burn and blister the skin. It is
also advisable to wear protective clothing (goggles,
rubber gloves and apron) when working with it.*
B. Should battery acid accidentally splatter into the
eyes or onto the face, rinse the affected area
immediately with clean cold water. If there is any
further discomfort, seek prompt medical attention.
C. If acid spills on clothing, first dilute it with clean
water, then neutralize with a solution of ammonia/
water or baking soda/water.
D. Since battery acid is corrosive, do not pour it into
any sink or drain. Before discarding empty elec-
trolyte containers, rinse them with a neutralizing
solution.
E. NEVER connect or disconnect charger clips to
battery while charger is turned on as it can cause
sparks.
F. Keep all lighted materials (cigarettes, matches,
lighters) away from the battery as the hydrogen
gas generated during charging can be combustible.
G. As a further precaution, only charge the battery in
a well-ventilated area.
*Always shield eyes, protect skin and clothing
when working near batteries.
3