Filter
Top Products
RCC130H-CRACK SAW OPERATION AND PARTS MANUAL REV #1 (11/18/04) PAGE 21
ASSEMBLY INSTRUCTIONS/OPERATIONS
4) Refer to the material supplied by the engine
manufacturer for the correct starting, operation and
stopping procedures.
5) The RCC130H Series Crack Saw is equipped
with a non slip type foot pad to provide additional
stability during the engine starting process. FIGURE
17 depicts a proper operator position for starting the
Crack Saw.
FIGURE 17
6) The RCC130H Series gasoline powered Crack
Saw is not equipped with a centrifugal clutch
assembly. The gasoline engine is directly coupled to
the arbor shaft by a V-belt reduction.
DANGER
AS SOON AS THE ENGINE STARTS, THE
OPERATOR MUST BE IN A POSITION TO
ASSUME DIRECT AND FULL CONTROL OF THE
CRACK SAW. FAILURE TO ASSUME DIRECT
AND FULL CONTROL CAN RESULT IN
PROPERTY DAMAGE AND/OR PERSONAL
INJURY.
7) Allow the engine to properly "warm up" and
operate without the requirement for choking. Check
for excessive machine noise and/or vibration.
DANGER
DO NOT OPERATE A GASOLINE ENGINE IN
CLOSED SPACES WITHOUT PROPER
VENTILATION. GASOLINE ENGINES PRODUCE
CARBON MONOXIDE FUMES. BREATHING
CARBON MONOXIDE FUMES CAN RESULT IN
PROPERTY DAMAGE AND/OR PERSONAL
INJURY. EXCESSIVE LEVELS OF CARBON
MONOXIDE CAN CAUSE DEATH.
8) Stop the engine in accordance with the
instructions as described in the material supplied by
the engine manufacturer.
CAUTION
If the Crack Saw and/or an individual
component/accessory does not appear to be
functioning properly, STOP and do not further
operate the Crack Saw until the proper
corrective action has been completed. If there
are any questions regarding the proper
operation of the Crack Saw, contact the
Customer Service Department BEFORE further
utilization. There is no charge for this service.
OPERATING THE RCC130H CRACK SAW ON
THE JOB SITE.
DANGER
THE SAWING PROCESS PRODUCES
EXCESSIVE NOISE, VIBRATION AND FLYING
DEBRIS. ALL OPERATORS AND WORK
PERSONNEL IN THE VICINITY OF THE CRACK
SAW MUST WEAR APPROPRIATE SAFETY EYE
WEAR AND HEARING PROTECTION DEVICES.
OTHER SAFETY APPAREL AND/OR
PROCEDURES, DEEMED NECESSARY BY
SUPERVISORY PERSONNEL MUST ALSO BE
WORN AND/OR PRACTICED BY ALL
APPROPRIATE PERSONNEL.
DANGER
EXERCISE EXTREME CAUTION WHEN
OPERATING THE CRACK SAW IN THE VICINITY
OF DECK INSERTS, PIPES, COLUMNS,
OPENINGS, LARGE CRACKS, UTILITY OUTLETS
OR ANY OBJECT PROTRUDING FROM THE
SURFACE. CONTACT WITH SUCH OBJECTS
CAN LEAD TO LOSS OF MACHINE CONTROL,
RESULTING IN PROPERTY DAMAGE AND/OR
PERSONAL INJURY.
DANGER
DO NOT OPERATE A GASOLINE ENGINE IN
CLOSED SPACES WITHOUT PROPER
VENTILATION. GASOLINE ENGINES PRODUCE
CARBON MONOXIDE FUMES. BREATHING
CARBON MONOXIDE FUMES CAN RESULT IN