Filter
Top Products
Table of Contents
RC45180 & RCM45180 Rotary Cutter 312-382M 7/14/08
Land Pride
Table of Contents
© Copyright 2008 All rights Reserved
Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, Land
Pride assumes no responsibilityfor errorsor omissions. Neitheris any liabilityassumed for damagesresulting from the useof the information contained herein.Land Pride reserves
the right to revise and improve itsproducts as it seesfit. This publication describes thestate of this productat the time ofits publication, andmay not reflectthe product in thefuture.
Land Pride is a registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
Important Safety Information . . . . . . . . . . .1
Safety Notations . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Safety Rules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Tire Handling & Repair . . . . . . . . . . . . . . . . . . . 2
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Introduction . . . . . . . . . . . . . . . . . . . . . . . .7
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . 7
Terminology: . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Definitions: . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . 7
Serial Number Plate . . . . . . . . . . . . . . . . . . . . . 7
Section 1 Assembly and Setup . . . . . . . . .8
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . 8
Before You Start . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Dealer Cutter Assembly & Preparations . . . . . . . . 8
Left & Right Wing Axle Assembly . . . . . . . . . . . . . . 8
Hitch Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Slow Moving Vehicle
Bundle Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Hydraulic Plumbing . . . . . . . . . . . . . . . . . . . . . . . . 9
Tractor Hookup . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Section 2 Operating Instructions . . . . . .12
Operating Check List . . . . . . . . . . . . . . . . . . . . . . 12
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Section 3 Adjustments . . . . . . . . . . . . . . .14
Center Deck Level Adjustments . . . . . . . . . . . . . . 14
Center Deck Rear Axle Arms Adjustment . . . . . . 14
Wing Deck Level Adjustments . . . . . . . . . . . . . . . 15
Wing Deck Tailwheel Rubber Bumper Adjustment 15
Section 4 Troubleshooting . . . . . . . . . . .16
Section 5 Maintenance and Lubrication .17
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
Service Cutting Blades . . . . . . . . . . . . . . . . . . . . .17
Skid Shoes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
Clutch Run-In . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19
Axle Hub Bearing . . . . . . . . . . . . . . . . . . . . . .19
Wing Hinges (6) . . . . . . . . . . . . . . . . . . . . . . . .19
Ratchet Jack . . . . . . . . . . . . . . . . . . . . . . . . . .19
Axle Rockshaft & Axle Link . . . . . . . . . . . . . . .20
Main Hitch . . . . . . . . . . . . . . . . . . . . . . . . . . . .20
Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20
Divider Box . . . . . . . . . . . . . . . . . . . . . . . . . . .20
Driveline Shaft . . . . . . . . . . . . . . . . . . . . . . . . .21
Drive line Shafts . . . . . . . . . . . . . . . . . . . . . . .21
PTO Constant Velocity Shaft . . . . . . . . . . . . . .21
4-Plate Slip Clutch . . . . . . . . . . . . . . . . . . . . . . . .22
Disassembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22
Section 6 Specifications and Capacities 23
Section 7 Appendix . . . . . . . . . . . . . . . . .24
Tire Inflation Chart . . . . . . . . . . . . . . . . . . . . . . . .24
Torque Values Chart for Common Bolt Sizes . . . .24
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25