Filter
Top Products
10/28/05
© Copyright 2005 All rights Reserved
LandPride providesthispublication“asis”without warrantyofanykind,either expressedorimplied.While every precautionhasbeentakeninthe preparationofthismanual,
Land Pride assumes no responsibilityfor errorsor omissions. Neither is any liability assumed for damages resulting from the use ofthe information contained herein. Land
Pride reserves the right to revise and improve its products as it seesfit. This publication describes the state of this product at the time of its publication, and may not reflect
the product in the future. The illustrations in this manual are not intended for safe and proper assembly or disassembly of equipment. The illustrations are intended for
ordering parts only.
Land Pride is registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
Land Pride
Table of Contents
Information . . . . . . . . . . . . . . . . . . . . . . . . .1
Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1
Introduction . . . . . . . . . . . . . . . . . . . . . . . .6
Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . 6
Terminology: . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Definitions: . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . 6
Serial Number Plate . . . . . . . . . . . . . . . . . . . . . . . . 6
Further Assistance . . . . . . . . . . . . . . . . . . . . . . . . . 6
Backhoe Operation, Maintenance & Safety Tips . . 7
Section 1 Assembly and Set-Up . . . . . . . . .8
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . 8
Skid Steer Requirements . . . . . . . . . . . . . . . . . . . . 8
Hydraulic System Requirements . . . . . . . . . . . . . . 8
Select Hydraulic System . . . . . . . . . . . . . . . . . . . . 8
Tractor System . . . . . . . . . . . . . . . . . . . . . . . . . 8
Power Beyond Hydraulic System . . . . . . . . . . . 8
Power Beyond Hydraulic Systems . . . . . . . . . . . . . 8
Power Beyond and Closed Center Kit . . . . . . . . 8
Closed Center Hydraulic Systems . . . . . . . . . . . . . 9
Power Beyond & Closed Center Kit . . . . . . . . . . 9
Choose the Appropriate Hosing . . . . . . . . . . . . . . 10
Independent PTO Hydraulic Pump System . . . 10
For All Tractors . . . . . . . . . . . . . . . . . . . . . . . . . . 12
For John Deere Tractors . . . . . . . . . . . . . . . . . . . 12
Mounting The Backhoe . . . . . . . . . . . . . . . . . . . . 12
Lower Link Hitch Bracket Installation . . . . . . . 13
Backhoe Stabilizer Kit Installation . . . . . . . . . . 14
Seat Assembly . . . . . . . . . . . . . . . . . . . . . . . . 15
Bucket Installation . . . . . . . . . . . . . . . . . . . . . . 15
Skid Steer Hook-Up . . . . . . . . . . . . . . . . . . . . 15
Optional Equipment Assemblies . . . . . . . . . . . . . 16
Locking Bar . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Ripper Tooth . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Section 2 Operating Instructions . . . . . . . .17
Preparing For Operation . . . . . . . . . . . . . . . . . . .17
Preparing The Backhoe . . . . . . . . . . . . . . . . . .17
Preparing The Tractor . . . . . . . . . . . . . . . . . . .17
Operating The Backhoe . . . . . . . . . . . . . . . . . . . .17
Transporting The Backhoe . . . . . . . . . . . . . . . . . .17
Control Functions . . . . . . . . . . . . . . . . . . . . . . . . .18
Stabilizers . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
Dipper Stick And Bucket . . . . . . . . . . . . . . . . .18
Digging Suggestions . . . . . . . . . . . . . . . . . . . . . .19
Observe the following cautions while digging. .19
Digging at the Correct Angle . . . . . . . . . . . . . . . .19
Dipper Stick & Boom Angle . . . . . . . . . . . . . . .19
Bucket Angle . . . . . . . . . . . . . . . . . . . . . . . . . .20
Section 3 Maintenance and Lubrication . . .21
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . .21
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21
Bucket Tooth Replacement . . . . . . . . . . . . . . . . .21
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22
Bucket Pivot . . . . . . . . . . . . . . . . . . . . . . . . . .22
Bucket Pivot (End of Stick) . . . . . . . . . . . . . . .22
Bucket Cylinder Base End . . . . . . . . . . . . . . . .22
Dipper Stick Pivot . . . . . . . . . . . . . . . . . . . . . .22
Dipper Stick Cylinder Base End . . . . . . . . . . . .23
Boom Cylinder Rod End . . . . . . . . . . . . . . . . .23
Boom Pivots (Both Sides) . . . . . . . . . . . . . . . .23
Boom Pivot (Unerneath at end of Boom) . . . . .23
Boom Cylinder Base End . . . . . . . . . . . . . . . .24
Stabilizer Cylinder Rod End (Both Sides) . . . .24
Stabilizer Arms (Both Sides) . . . . . . . . . . . . . .24
Boom Swing Pivot . . . . . . . . . . . . . . . . . . . . . .24
Boom Swing Cylinder Rod End (Both Sides) . .25
Boom Swing Cylinder Base End . . . . . . . . . . .25
Section 4 Specifications and Capacities . .26
Section 5 Features and Benefits . . . . . . . .27
Section 6 Troubleshooting . . . . . . . . . . . . .28
Section 7 Appendix . . . . . . . . . . . . . . . . . .30
Torque Values Chart For Common Bolt Size . 30
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Table of Contents