Filter
Top Products
35
6.3 ENGINE WILL NOT START.
a) Make sure battery is at a full charge.
b) Be sure the throttle control is midway between the “SLOW” and “FAST” positions,
and the choke is in the “ON” position for a cold engine or the “OFF” position for a
warm engine.
c) Make sure there is fuel in the fuel tank and that the fuel valve is open.
d) Be sure the seat switch is working properly.
e) Make sure the parking brake is set and motion control levers are moved out
(neutral lock position).
f) Check that the PTO is disengaged.
g) Check that the spark plug wires are properly connected.
h) Check for loose or faulty wiring connections.
i) Check for corrosion at all wiring connections. Even minor corrosion may cause a
faulty connection. Clean connector terminals thoroughly with electrical contact
cleaner, apply dielectric grease and reconnect.
NOTE: When disconnecting electrical connectors DO NOT pull on the wires to
separate the connectors.
NOTE: After carefully checking the above steps, attempt to start the engine. If it
does not start, contact your authorized Exmark service dealer.
IMPORTANT: It is essential that all operator safety mechanisms be connected
and in proper operating condition prior to mower use.
When a problem occurs, do not overlook the simple causes. For example, starting
problems could be caused by an empty fuel tank.
The following table lists some of the common causes of trouble. DO NOT attempt to
service or replace major items or any items that call for special timing of adjustments
procedures (such as valves, governor, etc.). Have this work done by your Engine
Service Dealer.
ENGINE TROUBLESHOOTING TABLE
PROBLEM
NO
FUEL
IMPROPER
FUEL
DIRT IN
FUEL LINE
DIRTY AIR
FILTER
FAULTY
SPARK
PLUG
ENGINE
OVERLOADED
BLOCKED
FUEL
FILTER
INCORRECT
OIL
LEVEL
DIRTY
AIR
SCREEN
Will not start
X X XXXX
Hard starting
X X X X X X X
Stops suddenly
X X X X X X X
Lacks power
X X X X X X X X
Operates
erratically
X X X X X X X
Knocks or pings
X X X
Skips or misfires
X X X X X
Backfires
X X X X X
Overheats
XX X X X
High fuel
consumption
X X X X