Filter
Top Products
2
Briggs & Stratton Power Products Home Generator
Installation Manual
TABLE OF CONTENTS EQUIPMENT
DESCRIPTION
This product is intended for use as an optional home
standby system which provides an alternate source of
electric power and to serve loads such as heating,
refrigeration systems, and communication systems that,
when stopped during any power outage, could cause
discomfort, or the like.This product DOES NOT qualify for
emergency standby as defined by NFPA 70 (NEC).
This manual contains installation, startup and adjustment
instructions for a Home Standby Generator that supplies
120/240 Volt, single phase, 60Hz devices.The Home Standby
Generator may be operated on LP or natural gas fuel.A
separate operator’s manual (part number 192384GS)
contains specifications, operating and maintenance
instructions for these models.
Every effort has been made to ensure that the information in
this manual is both accurate and current. However, the
manufacturer reserves the right to change, alter or otherwise
improve the system at any time without prior notice.
CUSTOMER
RESPONSIBILITIES
• Read and follow the instructions given in the Operator’s
Manual, especially the section regarding selecting essential
circuits.
• Follow a regular schedule in maintaining, caring for and
using your Home Standby Generator, as specified in the
Operator’s Manual.
INSTALLER
RESPONSIBILITIES
• Read and observe the safety rules.
• Refer to the list of recommended UL approved transfer
switches that is compatible with the Home Standby
Generator elsewhere in the carton.
• Read and follow the instructions given in this Installation
and Start-up Manual.
IMPORTANT: If operating the generator below 40°F,
it is recommended that a battery and oil warmer be
installed. If operating the generator below 32°F, a
battery and oil warmer MUST be installed. Both
items are available at your local servicing dealer.
TABLE OF CONTENTS . . . . . . . . . . . . . . . . . . . . . . . . . . 2
EQUIPMENT DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . 2
CUSTOMER RESPONSIBILITIES . . . . . . . . . . . . . . . . . . . . 2
INSTALLER RESPONSIBILITIES . . . . . . . . . . . . . . . . . . . . 2
SAFETY RULES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
INSTALLATION PROCEDURES . . . . . . . . . . . . . . . . . . . . 4
Unpacking Precautions . . . . . . . . . . . . . . . . . . . . . . . . 4
Delivery Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Shipment Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Required Specialty Tools/Equipment . . . . . . . . . . . . . . 4
Home Standby Generator Location . . . . . . . . . . . . 4-5
Fuel and Electrical Inlet Dimensions . . . . . . . . . . . . . . 5
Lifting the Generator . . . . . . . . . . . . . . . . . . . . . . . . 5-6
Access Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7
THE GASEOUS FUEL SYSTEM . . . . . . . . . . . . . . . . . . . 7-8
Fuel Consumption . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Fuel Pipe Sizing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
KNOW YOUR SYSTEM CONTROL BOARD . . . . . . . . . 10
Generator AC Connection System . . . . . . . . . . . . . 11
Grounding the System . . . . . . . . . . . . . . . . . . . . . . . 11
Utility Control Circuit Connection . . . . . . . . . . . . . 11
Fault Detection System . . . . . . . . . . . . . . . . . . . . . . . 11
System Control Panel . . . . . . . . . . . . . . . . . . . . . . . . 12
BEFORE INITIAL ENGINE START-UP . . . . . . . . . . . . . . 12
Engine Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Battery Connection . . . . . . . . . . . . . . . . . . . . . . . 12-13
Fuel Supply System . . . . . . . . . . . . . . . . . . . . . . . . . . 13
FUEL SYSTEM SELECTION . . . . . . . . . . . . . . . . . . . . . . . 13
INITIAL START-UP (NO LOAD) . . . . . . . . . . . . . . . . . . 14
Engine Adjustment . . . . . . . . . . . . . . . . . . . . . . . . 14-15
AUTOMATIC OPERATION SEQUENCE . . . . . . . . . . . . 15
SETTING EXERCISE TIMER . . . . . . . . . . . . . . . . . . . . . . 16
INSTALLATION INSPECTION . . . . . . . . . . . . . . . . . . . . 16
Fuel Comparison Chart . . . . . . . . . . . . . . . . . . . . . . 17
Size of Propane Tank Required at Various Temperatures
When Kept at Least Half Full . . . . . . . . . . . 17
Copyright © 2006 Briggs & Stratton Power Products
Group, LLC. All rights reserved. No part of this material
may be reproduced or transmitted in any form by any
means without the express written permission of Briggs &
Stratton Power Products Group, LLC.