Filter
Top Products
Assembly 29
MAN0475 (9/21/2005)
ASSEMBLY INSTRUCTIONS
DEALER SET-UP INSTRUCTIONS
Assembly of this mower is the responsibility of the
Woods dealer. If should be delivered to the owner com-
pletely assembled, lubricated, and adjusted for normal
cutting conditions.
Complete Dealer Check Lists on page 33 when you
have completed the assembly.
The mower is shipped partially assembled. Assembly
will be easier if components are aligned and loosely
assembled before tightening hardware. Recommended
torque values for hardware are located on page 45.
Select a suitable working area. Open parts boxes and
lay out parts and hardware to make location easy.
Refer to illustrations, accompanying text, parts lists and
exploded view drawings.
Before working underneath, carefully read Oper-
ator’s Manual instructions, disconnect driveline,
raise mower, securely block up all corners with
jackstands, and check stability. Secure blocking
prevents equipment from dropping due to hydrau-
lic leak down, hydraulic system failures, or
mechanical component failures.
Always wear relatively tight and belted clothing
to avoid getting caught in moving parts. Wear
sturdy, rough-soled work shoes and protective
equipment for eyes, hair, hands, hearing, and head;
and respirator or filter mask where appropriate.
Uncrate Mower
1. Remove sides and top of mower shipping crate.
2. Remove lag screws and brackets that secure
mower to crate base.
3. Remove driveshaft wired to mower deck.
Install Front Offset Links
1. Loosen lock nuts at lower hitch point and rotate
offset link up off of gearbox as shown.
2. Tighten nut securely.
3. Repeat for opposite side.
NOTE: Front link with the PTO storage bracket should
be installed on right side of mower as shown in Figure
28.
Figure 28. Front Offset Links Installed
Install Rear Offset Links
1. Loosen nut (44) at rear frame lug and rotate offset
link (9) up as shown in Figure 29.
2. Repeat for opposite side.
3. Do not tighten at this time.
9. Link, rear offset
44. Nut, flanged lock 1/2 NC
Figure 29. Right Rear Offset Link Installed
CAUTION
PTO Storage Bracket
Rear Offset
Link
Front
Offset
Front Offset
Link
Lock Nuts
Link
CM905
44
9
(Rev. 12/23/2005)