Filter
Top Products
14
BOTTOM RAIL AND STRAP LAYOUT
11
Follow the instructions below to properly layout the rail and strap assemblies.
QUANTITIES NEEDED:
POOL SIZE 12x8 15x10 18x12 24x12 24x15 30x15 33x18
STRAP ASSEMBLIES 223 5 4 6 6
SHORT RAILS 224 8 61010
LONG RAILS 8101010101012
BOTTOM PLATES 688 8 8 810
EXAMPLE OF BASIC LAYOUT
Patio Block
Bottom Plate
Strap Assembly
Short
Bottom Rail
Long
Bottom Rail
31”
Bottom Rail
Ground Shield
(Optional)
BOTTOM
RAIL
BOTTOM PLATE
PATIO BLOCK
UNDER ROUND
SIDE PLATES
PRE WASHED SAND OR
SIFTED EARTH RECOMMENDED
REQUIREMENT CHART
POOL SIZE TONS YARDS
12’ x 8’ 1.4 Tons 0.9 Cu.
15’ x 10’ 1.8 Tons 1.2 Cu.
18’ x 12’ 2.4 Tons 1.6 Cu.
24’ x 12’ 3.3 Tons 2.2 Cu.
24’ x 15’ 3.8 Tons 2.5 Cu.
30’ x 15’ 4.8 Tons 3.2 Cu.
33’ x 18’ 6.0 Tons 4.0 Cu.
Mark out pool radius (1/2 pool width) using stakes "B"
as a reference. Form the two end semicircles by sliding
the long bottom rail groove up, into the bottom plates.
Lay out the strap assemblies as shown removing the
stakes as you go. The distance from strap to strap
is 36". Install the short bottom rail in between each
strap as shown.
Bring the required amount of sifted earth or
pre-washed sand into the pool area at this time.
Refer to chart above for the required minimum
amount. Place patio blocks under all bottom plates
and end of strap assemblies.
Inside Pool
INSERT WALL INTO BOTTOM RAILS
12
SKIMMER INLET
4’ x 4’ Plywood
SKIMMER OUTLET
Remove wall from carton.
NOTE: the UP arrow on wall.
Determine starting point as the filter
inlet and outlet holes are at the
beginning of the wall.
Starting at the center of a bottom plate
insert the bottom edge of wall into the
groove on the bottom rail. Make sure
that the cutouts for filter inlet and outlet
are on the top portion of the wall and will
not be hidden behind a vertical.
If the wall ends do not meet, adjust the bottom rails
in or out of the bottom plates. The spacing in all bottom plates should be equal.
Make sure that the starting position of the wall and skimmer inlet and outlet holes are on the same end of the pool.