Filter
Top Products
OPERATION
OPERATION
Operation Section 4-25
© 2004 Alamo Group Inc.
FM84A 09/03
10.4 PTO RPM and Ground Speed
Ground speed is achieved by transmission gear selection and not by the engine operating speed. The operator
may be required to experiment with several gear range combinations to determine the best gear and range which
provides the most ideal performance from the mower and most efficient tractor operation. As the severity of cutting
conditions increase, the ground speed should be decreased by selecting a lower gear to maintain the proper
operating PTO speed.
Ground speed for mowing will depend upon the height, type, and density of vegetation to be cut. Recommended
speed for efficient mower performance is between 2 and 5 mph. Operate the mower at its full rated speed to
maintain blade speed for a clean cut. Refer to the tractor operator’s manual or the tractor instrument panel for the
engine speed and gear to provide the required PTO and desired ground speed. Make sure that the mower is
operating at its full rated speed before the blades make contact with vegetation. If it becomes necessary to
temporarily regulate engine speed, increase or decrease the throttle gradually.
WARNING!
Do not exceed the rated PTO speed for the Implement. Excessive PTO speeds can
cause Implement driveline or blade failures resulting in serious injury or death. (SG-26)
Before engaging the PTO, make certain that the area is clear of bystanders and passersby. Set the tractor
engine speed at approximately 540 RPM before engaging the PTO. Shift the PTO control to the on position, and
slowly increase the engine speed until the PTO is operating at the rated speed. If you hear unusual noises or see
or feel abnormal vibrations, disengage the PTO immediately. Inspect the mower to determine the cause of the
noise or vibration and repair the abnormality
.
Do not let the Blades turn when the Mower deck is raised for any
reason, including clearance or for turning. Raising the Mower deck
exposes the cutting blades which creates a potentially serious hazard
and could cause serious injury or even death from objects thrown
from the blades. (SRM-7)
DANGER!
10.3 Engaging the Power Take Off (PTO)
Do not put hands or feet under Mower decks. Blade contact can result
in serious injury or even death. (SGM-9)
DANGER!