Filter
Top Products
PAGE 10 — INDUSTRIAL GENERATOR SETS — APPLICATION & INSTALLATION MANUAL — REV. #4 (09/07/07)
IMPORTANT SAFETY INSTRUCTIONS
Operation Safety
■
ALWAYS be sure the operator is familiar with proper safety
precautions and operations techniques before using
generator.
■
DO NOT allow unauthorized people near equipment.
■
ALWAYS wear ear protection when working in
a loud environment.
■
NEVER run engine without air filter. Engine damage will
occur.
■
DO NOT leave the generator running in the MANUAL
mode unattended.
■
NEVER use accessories or attachments which are not
recommended by MQ Power for this equipment. Damage
to the equipment and/or injury to user may result.
■
Manufacturer does not assume responsibility for any
accident due to equipment modifications.
■
ALWAYS check the machine for loosened parts or bolts
before starting.
Emergencies
Always be prepared for an emergency such as fire, personnel
injury, or other emergency situation. It is important to identify
all possible emergency situations and to provide adequate
prevention methods and response methods.
■
Install the appropriate fire extinguishers in convenient
locations. Consult the local fire department for the correct
type of extinguisher to use. DO NOT use foam on
electrical fires. Use extinguishers that are rated ABC by
the National Fire Protection Association (NFPA).
■
ALWAYS know the location of the
nearest
fire extinguisher
.
■
ALWAYS provide an emergency escape route in the event
of an emergency.
■
ALWAYS know the location of the nearest
first aid kit
.
■
In emergencies
always
know the location of the nearest
phone or
keep a phone on the job site
. Also know the
phone numbers of the nearest
ambulance
,
doctor
and
fire department
. This information will be invaluable in the
case of an emergency.
Always disconnect the battery cable negative (first) before
performing service on the generator. Reconnect battery cable
negative (last) after service is complete.
Maintenance Safety
When performing maintenance on MQ Power generator sets,
it is important to prevent automatic start-up of the unit by a
remote contact closure by disconnecting the engine battery
before servicing.
■
Keep the machinery in proper running condition.
■
NEVER lubricate components or attempt service on a
running machine.
■
Always allow the machine a proper amount of time to
cool before servicing.
■
Fix damage to the machine immediately and always
replace broken parts.
■
Dispose of hazardous waste properly. Examples of
potentially hazardous waste are used motor oil, coolant,
fuel, and fuel filters.
■
DO NOT use plastic containers to dispose of hazardous
waste.
■
DO NOT pour waste, oil, coolant or fuel directly onto the
ground, down a drain, or into any water source
■
Whenever necessary, replace nameplate, operation and
safety decals when they become difficult read.
■
Never leave rags or tools on or near the generator-set.
■
Refer to the
Volvo Engine Owner's Manual
for engine
technical questions or information.