Country Home Products FIELD and BRUSH MOWER Lawn Mower User Manual


 
CALL TOLL FREE 1-800-DR-OWNER 23
CHAPTER 5
MAINTAINING THE DR FIELD AND BRUSH MOWER
This chapter covers regular maintenance procedures that will ensure the best performance and long life of
your machine. For engine maintenance, please refer to the engine owner’s manual that came with your
mower. Service intervals listed in the checklist below supercede those listed in the engine owner’s manual.
SOME OF THE FOLLOWING PROCEDURES REQUIRE ACCESS TO THE UNDERSIDE OF THE MACHINE. IF
YOU NEED TO TIP THE MACHINE BACK OR ON ITS SIDE (WITH THE DISCHARGE CHUTE FACING UP),
YOU MUST FIRST DISCONNECT THE SPARK PLUG WIRE(S), DRAIN THE OIL AND GAS, AND REMOVE THE
AIR FILTERS.
Regular Maintenance Check List
NOTE: Service intervals shown are considered maximum under normal operating conditions. Increase frequencies
under extremely dirty or dusty conditions.
Procedure
Before Each Use Every 25 Hours Every 100 Hours
Check Operator Presence Switch
Check Engine Oil Level
Check General Equipment Condition
Check Blade for Sharpness
Lubricate Grease Fittings
Lubricate Clutch and Brake Cables*
Lubricate Chain and Lock In/Out Sleeve*
Check Tire Pressure
Change Engine Oil and Filter** 1
st
time 5 hours
Check Parking Brake Adjustment
Clean Engine Exterior and Cooling Fins
Check All Belt Tensions and Condition
Check cable connections
Replace Air Filter and Precleaner**
Replace Spark Plug(s)
* FLUID FILM
®
lubricant or SAE 30 oil. NEVER use penetrating oil.
**
The engine on your DR may not have a Precleaner or Oil Filter.