Filter
Top Products
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 43
1
DCA-125USJ (50 HZ)— MAINTENANCE
Service Daily
If the engine is operating in very
dusty
or
dry grass
conditions, a
clogged air cleaner will result. This can lead to a loss of power,
excessive carbon buildup in the combustion chamber and high
fuel consumption. Change air cleaner more
frequently
if these
conditions exists.
Fuel Addition
Add diesel fuel (the grade may vary according to season and
locations).
Removing Water from the Fuel Tank
After prolonged use, water and other impurities accumulate in
the bottom of the tank. Occasionally inspect the fuel tank for
water contamination and drain the contents if required.
During cold weather, the more empty volume inside the tank,
the easier it is for water to condense. This can be reduced by
keeping the tank full with diesel fuel.
General Inspection
Prior to each use, the generator should be cleaned and inspected
for deficiencies. Check for loose, missing or damaged nuts, bolts
or other fasteners. Also check for fuel, oil, and coolant leaks.
Engine Side (Refer to the Engine Instruction Manual). Use
Table 11 as a general maintenance guideline
Air Cleaner
Every 250 hours: Remove air cleaner element and clean the
heavy duty paper element with light spray of compressed
air. Replace the air cleaner as needed.
Air Cleaner with Dust Indicator
This indicator is attached to the air cleaner. When the air cleaner
element is clogged, air intake restriction becomes greater and
the dust indicator signal shows RED meaning the element needs
changing or service. After changing the air element, press the
dust indicator button to reset the indicator.
ECNANETNIAM/NOITCEPSNI.11ELBAT
srH01
YLIAD
srH052 srH005 srH0001
ENIGNE
sleveLdiulFenignEkcehC X
renaelCriAkcehC X
leveLdicAyrettaBkcehC X
noitidnoCtleBnaFkcehC X
skaeLrofkcehC X
straPfogninesooLrofkcehC X
*retliFdnaliOenignEecalpeR
1
X
retliFriAnaelC X
lwoBrotarepeSretaW/retliFleuFkcehC X
edistuOdnaedisnI,tinUnaelC X
retliFleuFegnahC X
*leveLnoitcetorPtnalooCkcehCdnarotaidaRnaelC
2
X
*tnemelEretliFriAecalpeR
3
X
*spmalCdnasesoHllakcehC
4
X
knaTleuFfoedisnInaelC X
ROTARENEG
smhoM3revOecnatsiseRnoitalusnIerusaeM X
gniraeBtroppuSraeRrotoRkcehC X
.ylnoemittsrif,sruoh001taretliffnalioenigneecalpeR1*
.tnaloocenigneehtegrahcerot")S'ACS(sevitaddAtnalooClatnemelppuS"ddA2*
H.ni52(mm526fomuccavaswohsrotacidninoitcirtsernehwtnemeleretlifriayramirpecalpeR3* 2 .)0
htiw,toofrephcni2/1atsaeltasiesohybolbehtfoepolsehttahterusne,decalperebotsdeenesohybwolbfI4*
.lioro/d
naerutsiomtcellocdluoctahtspidrosgason