Filter
Top Products
-- 7 --
Idle Speed Screw
If you require f urther assistance or areunsure
about performing this procedure, contact an
authorized service dealer.
REPLACE SPARK PLUG
Replace spark plug each year to ensure the
engine starts easier and runs better. Set
spark plug gap at 0.025 inch. Ignition timing is
fixed, nonadjustable.
1. Twist, then pull off spark p lug boot.
2. Remove spark plug from cylinder and dis-
card.
3. Replace with Champion RCJ-6Y spark
plug and tighten securely with a 3/4 inch
socket wrench.
4. Reinstall the spark plug boot.
REPLACE FUEL FILTER
Toreplace fuel filter, drain unit byrunning it dry
of fuel, then remove fuel cap/retainer assem-
bly f rom tank. Pull filter from tank and remove
it from the fuel line. Install new fuel filter onfuel
line; reinstall parts.
Fuel Line
Fuel Filter
STORAGE
WARNING:
Perform the following
steps after each use:
S
Allow engine to cool, and secure the unit
before storing or transporting.
S
Store unit and fuel in a w ell ventilated area
where fuel vapors cannot reach sparks or
open flames from water heaters, electric
motors or switches, furnaces, etc.
S
Store unit with all guards in place. Position
unit so that any sharp object cannot acci-
dentally cause injury.
S
Store unit and fuel well out of the reach of
children.
SEASONAL STORAGE
Prepare unit for storage at end of season or if
it will not be used for 30 days or more.
If your unit i s to be stored for a period of time:
S
Clean the entire unit.
S
Store in a clean dry area.
S
Clean all parts and check for damage.
Have damaged parts repaired or replaced
by an authorized service dealer.
S
Keep all nuts, bolts, and screws tight.
S
Lightly oil external metal surfaces, includ-
ing the blade.
To oil the blade, do the following:
S
Stop the engine and al low blade to come to
a complete stop.
S
Ensure ON/OFF switch is in the OFF posi-
tion.
S
Disconnect the spark plug wire.
S
Apply a light machine oil along the edge of
the top strap as shown.
Top Strap
OIL
FUEL SYSTEM
Under FUELING ENGINE in the OPERA-
TION section of this manual, see message la-
beled IMPORTANT regarding the use of ga-
sohol in your engine. Fuel s tabilizer is an ac-
ceptable alternative in minimizing the formation
of fuel gum deposi ts during s tor age. Add stabi-
lizer to gasol ine in fuel t ank orfuel storage con-
tainer. Follow the mix instructions found on sta-
bilizer container. Run engine at least 5 minutes
after adding stabilizer.
ENGINE
S
Remove spark plug and pour 1 teaspoon of
40:1, 2-cycle engine oil (air cooled) through
the spark plug opening. Slowly pull the
starter rope 8 to 10 times to distribute oil.
S
Replace spark plug with new one of recom-
mended type and heat range (see RE-
PLACE SPARK PLUG section).
S
Clean air filter.
S
Check entire unit for loose screws, nuts,
and bolts. Replace any damaged, broken,
or worn parts.
S
At the beginning of the next season, use
only fresh fuel having the proper gasoline to
oil ratio.
OTHER
S
Do not store gasoline from one season to
another.
S
Replace your gasoline can if it starts to rust.