Hustler Turf none Lawn Mower User Manual


 
9-10 333559 09/08
The electrical system is a 12 volt, negative ground. Recommended battery size is a garden tractor BCI
group UIR with 225 or better cranking AMP rating. A maintenance-free battery is recommended. Otherwise, fol-
low battery manufacturer’s maintenance, safety, storing, and charging specification.
The Battery is located under the seat platform (FIG. 2).
WARNING:
Battery post, terminals, and related accessories contain lead and lead compounds–
chemicals known to the State of California to cause cancer and reproductive harm. Wash hands
after handling.
WARNING: Change batteries in an open well ventilated area, away from spark and flames.
Unplug charger before connecting or disconnecting from the battery. Wear protective clothing and
use insulated tools.
WARNING: Avoid skin and clothing contact with battery acid. Always wear eye protection when
checking the battery, acid can cause serious injury to skin and eyes. If contact occurs, flush area
with clean water and call physician immediately. Acid will also damage clothing. Do not drink the
battery electrolyte. Do not allow open flame near the battery when charging. Hydrogen gas forms
inside the battery. This gas is both toxic and flammable and may cause an explosion if exposed to
flame. Always remove the negative ground first and replace it last. Do not overfill battery.
Electrolyte may overflow and damage paint, wiring or structure. When cleaning the battery, use
soap and water. be careful not to get soap and water into the battery. Clean the battery terminals
with a solution of four parts water and one part baking soda when they become corroded.
WARNING: Shorts caused by battery terminals or metal tools touching metal tractor
components can cause sparks. Sparks can cause a battery gas explosion which will result in
personal injury. Prevent the battery terminals from touching any metal tractor parts when removing
or installing the battery. Do not allow metal tools to short between the battery terminals and metal
tractor parts.
WARNING: Incorrect battery cable routing could cause damage to the tractor and battery
cables. This can cause sparks which can cause a battery gas explosion which will result in
personal injury. Always disconnect the negative (black) battery cable before disconnecting the
positive (red) cable.
Common circuit failures are usually caused by shorting, corroded or dirty terminals, loose connection,
defective wire insulation or broken wires. Switches, solenoids and ignition components may also fail, causing
a shorted or open circuit.
The electrical system is protected by fuses located on the right fuel tank instrument panel FIG. 3). The
fuses are as follows:
Before attempting any failure diagnosis of the electrical system, use a test light or voltmeter to check the
FIG. 2
Main 20 amp, blade type
Clutch/Aux 10 amp, blade type
BATTERY