Filter
Top Products
15
S
Replace with Champion RCJ--7Y spark
plug and tighten securely with a 3/4 inch
socket wrench. Spark p lug gap should be
0.025 inches.
S
Reinstall the s park plug boot.
S
Reinstall the cylinder cover and 3 screws.
Tighten securely.
Screws
Spark
Plug Boot
Spark
Plug
Cylinder
Cover
STORAGE
WARNING:
Stop engine and allow
to cool, and secure the unit before storing or
transporting in a vehicle. Store unit and fuel
in an area where fuel vapors cannot reach
sparks or open flames from water heaters,
electric motors or switches, furnaces, etc.
Store unit with all guards inplace. Position so
that any sharp object cannot accidentally
cause injury to passersby. Store the unit out
of reach o f children.
S
Before storing, drain all fuel from the unit.
Start engine and allow t o run until it s tops.
S
Clean the unit before storing. Pay particu-
lar attention to the air intake area, keeping
it free of debris. Use a mild detergent and
sponge to c lean the plastic surfaces.
S
Donot store theunit orfuel in a closed a rea
where fuel vapors can reach sparks or an
open flame from hot water heaters, electric
motors or switches, furnaces, etc.
S
Store in a dry area out of the reach of chil-
dren.
CAUTION
: It is im portant to prevent gum
deposits from forming in essential fuel system
parts such as the carbur etor, fuel filter, fuel
hose, or fuel tank during storage. Alcohol
blended fuels (called gasohol or using e thanol
or methanol) c an attract m oisture which leads
to fuel mixture separation and formation of
acids during storage. Acidic gas can damage
the engine.
TROUBLE CAUSE REMEDY
Engine will not
start or will run
only a few
seconds after
starting.
S
Ignition switch off.
S
Engine flooded.
S
Fuel tank empty.
S
Spark plug not firing.
S
Fuel not reaching
carburetor.
S
Move ignition switch to ON.
S
See “Difficult Starting” in
Operation Section.
S
Fill tank with correct fuel mixture.
S
Install new spark plug.
S
Check for dirty fuel filter; replace.
Check for kinked or split fuel line;
repair or replace.
Engine will
not idle
properly.
S
Carburetor requi res
adjustment
S
Crankshaft seals worn.
S
Contact a n Authorized Service Dealer.
S
Contact a n Authorized Service Dealer.
S
Air filter dirty.
S
Spark plug fouled.
S
Carburetor requi res
adjustment.
Engine will not
accelerate,
lacks power,
or dies under
a load.
S
Clean or replace air filter.
S
Clean or replace plug
and regap.
S
Contact a n Authorized Service Dealer.
.
Engine
smokes
excessively.
S
Toomuchoilmixedwith
gasoline.
S
Empty fuel tank and refill with
correct fuel mixture..
WARNING:
Always stop unit and disconnect spark plug before performing all of
the recommended remedies below except remedies that require operation of the unit.
TROUBLESHOOTING TABLE