Filter
Top Products
Table of Contents
Safety Precautions and Instructions I.........................................................
Section 1 Introduction 1.....................................................................
1.1 Installation Standards 1..................................................
1.2 Generator Set Specifications 1............................................
1.3 Generator Set Operation 1...............................................
Section 2 Location and Mounting 3...........................................................
2.1 General Considerations 3................................................
2.2 Location 3.............................................................
2.3 Vehicle-Floor Mounting 3.................................................
Section 3 Cooling System 5..................................................................
3.1 Air Requirements 5......................................................
3.2 Block Heaters 5.........................................................
3.3 High Water Temperature Switch 5.........................................
3.4 Unit-Mounted Radiator Cooling 5..........................................
3.4.1 System Features 5..............................................
Section 4 Exhaust System 7.................................................................
4.1 Planning 8.............................................................
4.2 Clearance Requirements 8...............................................
4.3 Exhaust Piping, If Used 8................................................
Section 5 Fuel System 9.....................................................................
5.1 Gasoline 9.............................................................
5.1.1 Fuel Lines 10....................................................
5.2 Fuel Filters or Strainers 10.................................................
5.3 LP Gas 10..............................................................
5.4 Fuel Pump Lift and Fuel Consumption 11....................................
Section 6 Electrical System 13................................................................
6.1 Electrical Connections 13.................................................
6.2 AC Load Lead Connections 13.............................................
6.3 Circuit Protection 15......................................................
6.3.1 Circuit Breaker Considerations 15..................................
6.3.2 Circuit Breaker Installation 16......................................
6.4 ADC 2100 Continuous Power Mode Jumper 17...............................
6.5 Battery and Connections 18...............................................
6.6 Remote Connection 19...................................................
Section 7 Installation Drawing 21..............................................................
Section 8 Reconnection/Adjustments 25.......................................................
8.1 Four-Lead Reconnection 26...............................................
8.2 Advanced Digital Control (ADC 2100) 28....................................
8.2.1 Configuration Mode Time Out 28...................................
8.2.2 Controller Software Version Number 28..............................
8.2.3 Adjusting the Voltage, Gain, and Volts/Hz 29.........................
8.2.4 Voltage Adjustment 29............................................
8.2.5 Controller Configuration 32........................................
Appendix A Generator Selection and Wattage Requirements A-1.................................
Appendix B Abbreviations A-2................................................................