Filter
Top Products
2
Study these SAFETY RULES carefully before installing, operating
or servicing this equipment. Become familiar with this manual and
with the unit. The generator can operate safely, efficiently and reli-
ably only if it is properly installed, operated and maintained. Many
accidents are caused by failing to follow simple and fundamental
rules or precautions.
The manufacturer cannot anticipate every possible circumstance
that might involve a hazard. The warnings in this manual, and on
tags and decals affixed to the unit, are, therefore, not all-inclusive.
If using a procedure, work method or operating technique the
manufacturer does not specifically recommend, ensure that it is
safe for others. Also make sure the procedure, work method or
operating technique utilized does not render the generator unsafe.
n
Despite the safe design of this generator,
operating this equipment imprudently, neglect-
ing its maintenance or being careless can
cause
possible injury or death. Permit only respon-
sible and capable persons to operate or main-
tain this equipment.
Potentially lethal voltages are generated by
these machines. Ensure all steps are taken to
render the machine safe before attempting to
work on the generator.
n
Parts of the generator are rotating and/or
hot during operation. Exercise care near run-
ning generators.
GENERAL HAZARDS
For safety reasons, the manufacturer recommends that the •
installation, initial start-up and maintenance of this equipment
is carried out by an Authorized Service Dealer.
The generator engine releases DEADLY carbon monoxide gas •
through its exhaust system. This dangerous gas, if breathed
in sufficient concentrations, can cause unconsciousness or
even death. Never operate the generator set with the vehicle
inside any garage or other enclosed area. DO NOT OPERATE
THE GENERATOR IF THE EXHAUST SYSTEM IS LEAKING OR
HAS BEEN DAMAGED. SYMPTOMS OF CARBON MONOXIDE
POISONING ARE (a) inability to think coherently, (b) nausea,
(c) vomiting, (d) twitching muscles, (e) throbbing temples,
(f) dizziness, (g) headaches, (h) weakness, and (i) sleepi-
ness. IF EXPERIENCING ANY OF THESE SYMPTOMS, MOVE
INTO FRESH AIR IMMEDIATELY. IF SYMPTOMS PERSIST, GET
MEDICAL HELP. Shut down the generator and do not operate it
until it has been inspected and repaired.
Never sleep in the vehicle while the genset is running unless the •
vehicle has a working carbon monoxide detector. The exhaust
system must be installed in accordance with the genset instal-
lation manual. Make sure there is ample fresh air when operat-
ing the genset in a confined area.
The engine exhaust fumes contain carbon monoxide, which can •
be DEADLY. This dangerous gas, if breathed in sufficient con-
centrations, can cause unconsciousness or even death. This
exhaust system must be installed properly, in strict compliance
with applicable codes and standards. Following installation, do
nothing that might render the system unsafe or in noncompli-
ance with such codes and standards. The generator compart-
ment must be completely vapor sealed from the vehicle interior.
There must be no possibility of exhaust fumes entering the
vehicle interior. Never operate this equipment with a leaking or
defective exhaust system.
Keep hands, feet, clothing, etc., away from drive belts, fans, •
and other moving or hot parts. Never remove any drive belt or
fan guard while the unit is operating.
Adequate, unobstructed flow of cooling and ventilating air is •
critical to correct generator operation and is required to expel
toxic fumes and fuel vapors from the generator compartment.
Without sufficient cooling airflow, the engine/generator quickly
overheats, which causes serious damage to the generator. Do
not alter the installation or permit even partial blockage of ven-
tilation provisions, as this can seriously affect safe operation of
the generator.
When working on this equipment, remain alert at all times. •
Never work on the equipment when physically or mentally
fatigued.
Inspect the generator regularly, and contact the nearest Authorized •
Service Dealer immediately for parts needing repair or replace-
ment.
Before performing any maintenance on the generator, discon-•
nect its battery cables to prevent accidental start up. Disconnect
the cable from the battery post indicated by a NEGATIVE, NEG
or (–) first. Reconnect that cable last.
Never use the generator or any of its parts as a step. Stepping •
on the unit can stress and break parts, and may result in dan-
gerous operating conditions from leaking exhaust gases, fuel
leakage, oil leakage, etc.
n
SAVE THESE INSTRUCTIONS – The manufacturer suggests that these rules for safe operation be
copied and posted in potential hazard areas of the recreational vehicle. Safety should be stressed to
all operators and potential operators of this equipment.
Safety Rules