Filter
Top Products
37
TRACTOR STORAGE
If your tractor is not going to be operated for an
extended period of time (thirty days to approxi-
mately six months), the tractor should be prepared
for storage. Store the tractor in a dry and protected
location. If stored outside, cover the tractor (includ-
ing the tires) to protect it from the elements. The
procedures outlined below should be performed
whenever the tractor is placed in storage.
WARNING: Never store the tractor with
fuel in the tank indoors or in poorly
ventilated enclosures, where fuel
fumes may reach an open flame, spark
or pilot light as on a furnace, water
heater, clothes dryer, etc.
1. Change the engine oil and filter following the
instructions provided in CHANGING THE
ENGINE OIL AND FILTER in SECTION 5.
2. Drain and flush the cooling system. Refill with a
minimum 50/50 antifreeze and water coolant
solution. Use a higher percentage of antifreeze
if the tractor will be subjected to temperatures
below minus 30° F.
3. Clean the engine and the entire tractor
thoroughly.
4. Fill the fuel tank with FRESH high grade
Number Two diesel fuel.
5. Remove the glow plugs and pour a small
amount of engine oil into each cylinder.
Reinstall the glow plugs and slowly crank the
engine to distribute the oil.
6. Fully charge the battery, then disconnect the
negative cable at the battery to prevent possi-
ble discharge. Thoroughly clean the battery.
Recharge the battery periodically when in
storage.
NOTE: Remove the battery if exposed to pro-
longed periods of sub-freezing temperatures.
Store in a cool, dry location where tempera-
tures are above freezing.
7. Lubricate all lubrication points.
8. Jack up and block the tractor to remove the
weight from the tires if stored for a long period.
If not blocked up, reinflate the tires regularly.
NOTE: We do not recommend the use of a
pressure washer or garden hose to clean your
tractor. They may cause damage to electrical
components; spindles; pulleys; bearings; or the
engine. The use of water will result in shortened life
and reduce serviceability.
REMOVING THE TRACTOR FROM STORAGE
• Check the engine oil and coolant levels.
• Fully charge the battery and inflate the tires to
the recommended pressure.
• Start the engine and allow to idle for a few
minutes to ensure engine is operating properly.
• Drive the tractor without a load to make certain
all the tractor systems are functioning properly.