Filter
Top Products
12 Operation
MAN0875 (2/8/2011)
The PTO control must be in the “OFF” position and the
steering handles in the NEUTRAL position before unit
can be started.
A safety switch behind the operator’s seat will cause
the engine to stop if the operator leaves the seat with
the PTO or steering handles engaged. The engine will
also stop if the steering handles are moved from NEU-
TRAL while the parking brake is engaged or if the deck
jumper wire is not connected to the wire harness or the
deck safety switch is disengaged.
STARTING ENGINE
Do not run engine indoors. Exhaust gases con-
tain carbon monoxide, an odorless and deadly poi-
son.
To enhance starter life, use short starting cycles not
exceeding 10 seconds. If engine does not start within
10 seconds, stop cranking for 30 seconds; then repeat
starting procedures.
1. Position yourself on the power unit seat.
2. Set parking brake.
3. Place steering control handles in the NEUTRAL
position (pivoted outward).
4. Place PTO switch in the “OFF” position (down).
5. Place throttle approximately 1/3 open.
6. Turn key to “START”.
7. Ensure that the alternator and oil pressure lights
are off.
8. Warm up engine several minutes at medium
throttle.
NOTE: Choke as necessary to start. When engine
starts, release key immediately. Pull choke gradually
back until choke is off and engine is running smoothly.
NOTE: Allow engine a warm-up period regardless of
the season. Loading a cold engine will shorten its life.
Cold Weather Starting Tips
1. Use proper oil grade for temperature expected.
(Refer to engine manual for oil grade.)
2. Set throttle half way open.
3. A warm battery has better starting capacity than a
cold one.
4. Use fresh fuel, it is better for starting than leftover
fuel.
STARTING MOWER OR ATTACHMENT
Make sure people and objects are clear of
attachment and discharge area before engaging
PTO.
NOTICE
■ Never engage PTO if the mower blades are
plugged with grass or other material. This may
cause damage to the electric clutch.
1. With engine running, position throttle at half speed.
2. Engage PTO by pulling up on the PTO switch.
3. Move throttle to full speed and begin operation.
NOTE: Starting attachment at lower engine speed will
help prolong the life of the clutch and transmission
components.
Stopping Mower or Attachment
Push down on PTO switch.
NOTE: If attachment does not stop in five seconds, the
unit requires service.
PRACTICE OPERATION
Never allow children or untrained persons to
operate equipment.
Operating this unit is not difficult once you are familiar
with the use of the controls. Equip the power unit with
the attachment you will be using and practice in a flat
open area at half throttle setting until you are comfort-
able with the controls.
Do not operate attachment until you become proficient
with controls.
Uneven Terrain Operation
Do not operate on slopes greater than 15
degrees (27% grade).
Do not stop, start, or change directions sud-
denly on slopes.
Use extreme care and reduce ground speed on
slopes and rough terrain.