Filter
Top Products
-- 9 --
FUEL SYSTEM
Under FUELING ENGINE in the OPERA-
TIONsectionofthismanual,seemessagela-
beled IMPORT ANT regarding the use of ga-
sohol in your engine.
Fuel stabilizer is an acceptable alternative in
minimizing t he formation of fuel gum deposits
during storage. Addstabilizer to gasoline in fuel
tank or fuel storage container. F ollow the mix
instructions found o n stabilizer container . R un
engine atleast 5 minutes after adding stabilizer.
HELPFUL TIP
During storageof yourgas/
oilmixture,theoilwillsepa-
rate from the gas.
We recommend that you
shake the gas can weekly
toinsureproper blendingof
the gas and oil.
ENGINE
S Removespark plugandpour1teaspoonof
40:1,2-cycleengineoil(air cooled)through
the spark plug opening. Slowly pull the
starter rope 8 to 10 times to distribute oil.
S Replacespark plugwithnewoneofrecom-
mended type and heat range.
S Clean air filter.
S Check entire unit for loose screws, nuts,
and bolts. Replace any damaged, broken,
or worn parts.
S At the beginning of the next season, u se
onlyfreshfuelhavingthepropergasolineto
oil ratio.
OTHER
S Do not store gasoline from one season to
another.
S Replaceyourgasolinecanifitstartstorust.
TROUBLE
CAU SE REMEDY
Engine will not
start.
1. Engine flooded.
2. Fuel tank empty.
3. Spark plug not firing.
4. Fuel not reaching
carburetor.
5. Compression low .
1. See“Starting a Flooded Engine”
in Operation section.
2. Filltank with correct fuel mixture.
3. Ins tall new spark plug.
4. Check for dirty fuel filter; replace.
Check for kinked or split fuel line;
repair or replace.
5. Contact an authorized service dealer .
Engine will not
idle properly.
1. Fuel not reaching
carburetor.
2. Carburetor requires
adjustment.
3. Crankshaft seals worn.
4. Compression low .
1. Check for dirty fuel filter; replace.
Check for kinked or split fuel line;
repair or replace.
2. Contact an authorized service dealer .
3. Contact an authorized service dealer
4. Contact an authorized service dealer .
1. Air filter dirty.
2. Fuel not reaching
carburetor.
3. Spark plug fouled.
4. Carburetor requires
adjustment.
5. Carbon build up.
6. Compression low .
Engine will not
accelerate,
lacks power, or
dies under a
load.
1. Clean or replace air filter.
2. Check for dirty fuel filter; replace.
Check for kinked or split fuel line;
repair or replace.
3. Clean or replace spark plug
and re-gap.
4. Contact an authorized service dealer .
5. Contact an authorized service dealer .
6. Contact an authorized service dealer .
Engine smokes
excessively.
1. Choke partially on.
2. Fuel m ixture incorrect.
3. Air filter dirty .
4. Carburetor requires
adjustment.
1. Adjust choke.
2. Empty fuel tank and refill with
correct fuel mixture.
3. Clean or replace air filter.
4. Contact an authorized service dealer.
Engine runs hot.
1. Fuel mixture incorrect.
2. Spark plug incorrect.
3. Carburetor requires
adjustment.
4. Carbon build up.
1. See “Fueling Engine” in Operation
section.
2. Replace with correct spark plug.
3. Contact an authorized service dealer .
4. Contact an authorized service dealer .
TROUBLESHOOTING TABLE
WARNING: Always stopunitanddisconnect spark plugbefore performingany ofthe
recommended remedies below other than remedies that require operation of the unit.