Filter
Top Products
(5) Miscellaneous Items Used in Above Systems
(i)Electronic controls, if applicable
(ii)Hoses, belts, connectors, and assemblies.
(iii) Filter lock assy (gaseous fuel, if applicable)
I. MAINTENANCE STATEMENTS
It is your responsibility to have all scheduled inspection and maintenance services performed at
the times recommended in the 2001 and later Owner's Manual and to retain proof that inspection
and maintenance services are performed at the times when recommended. FUJI will not deny a
warranty claim solely because you have no record of maintenance; however, FUJI may deny a
warranty claim if your failure to perform required maintenance resulted in the failure of warranted
part. The proof which you maintain should be given to each subsequent owner of the engine.
You are responsible for performing the scheduled maintenance described below based on the
procedures specified in the 2001 and later Owner's Manual. The scheduled maintenance below
is based on a normal engine operating schedule.
PROCEDURE INTERVAL
1) Clean engine and check bolts & nuts : Every 8 hours (daily)
2) Check and refill engine oil : Every 8 hours (refill daily up to upper limit)
3) Change engine oil : Initial 20 hours and every 50 hours afterward
4) Change engine oil filter, if applicable : Initial 20 hours and every 200 hours thereafter
5)
Check muffler exhaust outlet, clean if necessary
: Every 50 hours or weekly
6) Clean spark plug : Every 50 hours (weekly)
7) Clean air cleaner : Every 50 hours
8) Check battery electrolyte fluid level : Every 50 hours
9) Clean fuel filter (and fuel tank, if applicable) : Every 200 hours (Monthly)
10) Clean and adjust spark plug and electrodes: Every 200 hours (Monthly)
11) Replace air cleaner element, if applicable : Every 200 hours
12) Clean carburetor : Every 500 hours
13) Remove carbon from cylinder head : Every 500 hours
14) Adjust valve clearance, if applicable : Every 500 hours
15) Check and adjust valve seats : Every 500 hours
16) Replace spark plug : Every 500 hours
17) Replace fuel lines : Every 1000 hours (Yearly)
18) Overhaul engine : Every 1000 hours
Note : More frequent maintenance may be necessary under dusty, dirty or severe conditions.
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページA7