Filter
Top Products
AIR FILTER
CAUTION: Do not clean filter ingasoline or
other flammable solvent to avoid creating a
fire hazard or producing harmful evapora-
tive emissions,
Cleaning the air filter:
A dirty air filter decreases engine perform-
ance and increases fuel consumption and
harmful emissions. Always clean after every
5 hours of operation.
• Clean cover and area around it to keep
dirt and sawdust from falling into carbure-
tor chamber when cover is removed.
Remove the parts as illustrated below.
Wash the filter in soap and water.
CARBURETOR ADJUSTMENTS
Your carburetor is equipped with ]imiter
caps. Carburetor adjustment is a compli-
cated task. We recommend that you take
your unit to an Authorized Service Dealer.
Damage will occur it you turn the needles
beyond the limiter stops,
BAR MAINTENANCE
If your saw cuts to one side, has to be forced
through the cut, or has been run with an im-
proper amount of bar lubrication it may be
necessary to service your bar. A worn bar
wiU damage your chain and make cutting
difficult.
Replace your bar ifbent or the inside rails of
the bar are worn.
• Clean the oil holes after each 5 hours of
operation
• Remove sawdust from bar groove period-
ically with a wire or putty knife.
Guide Bar
Groove
Oil Holes
CHAIN SHARPENING
Chain sharpening is a complicated task that
requires special tools. We recommended
you refer chain sharpening to a professional
chain sharpener. If you choose to perform
your own chain sharpening, call our
toll-free helpline and order a free chain
sharpening instruction guide. (See the back
page of this manual for the toll-free phone
number.)
IGNITION TIMING
Ignition timing is fixed and nonadjustable.
SPARK PLUG
Replace the spark plug yearly.
STORAGE
WARNING: Stop engine and allow to
cool, and secure the unit before storing or
transporting in avehicle. Store unit and fuel
in an area where fuel vapors cannot reach
sparks or open flames from water heaters,
electric motors or switches, furnaces, etc.
Store unit with all guards in place. Position
so that any sharp object cannot accidentally
cause injury to passersby. Store the unit out
of reach of children.
Before storing, drain all fuel from the
unit. Start engine and allow to run until it
stops.
• Clean the unit before storing. Pay particu-
lar attention to the air intake area, keeping
itfree of debris. Use a mild detergent and
sponge to clean the plastic surfaces.
• Do not store the unit or fuel in a closed
area where fuel vapors can reach sparks
or an open flame from hot water heaters,
electric motors or switches, furnaces, etc.
• Store in a dry area out of the reach of chil-
dren.
CAUTION: It is important to prevent gum
deposits from forming in essential fuel sys-
tem parts such as the carburetor, fuel filter,
fuel hose, or fuel tank during storage. Alco-
hol blended fuels (called gasohol or using
ethanol or methanol) can attract moisture
which leads to fuel mixture separation and
formation of acids during storage. Acidic
gas can damage the engine.
Engine will not start.
• Ignition switch off.
• Engine flooded.
• Fuel tank empty.
Spark plug not firing.
• Fuel not reaching carburetor.
Engine will not idle properly.
• Carburetor requires adjustment.
• Crankshaft seals worn.
Engine will not accelerate, lacks
power, or dies under a 1cad.
• Air filter dirty.
• Spark plug fouled.
Carburetor requires ad ustment.
Engine smokes excessively.
• Too much oil mixed with gasoline
Need Assistance?
Call 1-800-554-6723.
Need Service Part?
Contact your retailer.
11