Filter
Top Products
PAGE 40 — DCA-180SSV— OPERATION AND PARTS MANUAL — REV. #1 (04/14/10)
DCA-180SSV— MAINTENANCE
General Inspection
Prior to each use, the generator should be cleaned and
inspected for deficiencies. Check for loose, missing or
damaged nuts, bolts or other fasteners. Also check for fuel,
oil, and coolant leaks. Use Table 14 as a general maintenance
guideline Engine Side (Refer to the Engine Instruction
Manual)
Air Cleaner
Every 250 hours: Remove air cleaner element (Figure 56)
and clean the heavy duty paper element with light spray of
compressed air. Replace the air cleaner as needed.
Air Cleaner with Dust Indicator
This indicator (Figure 58) is attached to the air cleaner. When
the air cleaner element is clogged, air intake restriction
becomes greater and the dust indicator signal shows RED
meaning the element needs changing or service. After
changing the air element, press the dust indicator button to
reset the indicator.
ECNANETNIAM/NOITCEPSNI.41ELBAT
srH01
YLIAD
srH052 srH005 srH0001
ENIGNE
sleveLdiulFenignEkcehC X
renaelCriAkcehC X
leveLdicAyrettaBkcehC X
noitidnoCtleBnaFkcehC X
skaeLrofkcehC X
straPfogninesooLrofkcehC X
*retliFdnaliOenignEecalpeR
1
X
retliFriAnaelC X
lwoBrotarepeSretaW/retliFleuFkcehC X
edistuOdnaedisnI,tinUnaelC X
retliFleuFegnahC X
*leveLnoitcetorPtnalooCkcehCdnarotaidaRnaelC
2
X
*tnemelEretliFriAecalpeR
3
X
*spmalCdnasesoHllakcehC
4
X
knaTleuFfoedisnInaelC X
ROTARENEG
smhoM3revOecnatsiseRnoitalusnIerusaeM X
gniraeBtroppuSraeRrotoRkcehC X
.ylnoemittsrif,sruoh001taretliffnalioenigneecalpeR1*
.tnaloocenigneehtegrahcerot")S'ACS(sevitaddAtnalooClatnemelppuS"ddA2*
H.ni52(mm526fomuccavaswohsrotacidninoitcirtsernehwtnemeleretlifriayramirpecalpeR3* 2 .)0
htiw,toofrephcni2/1atsaeltasiesohybolbehtfoepolsehttahterusne,decalperebotsdeenesohybwolbfI4*
.lioro/d
naerutsiomtcellocdluoctahtspidrosgason
Figure 56. Air Cleaner/Indicator
The air filter should not be
changed until the indicator reads
“RED”. Dispose of old air filter it
may not be cleaned or reused.
NOTE