Filter
Top Products
5/05/06
Land Pride
Table of Contents
© Copyright 2006 All rights Reserved
LandPride providesthispublication“asis”without warrantyofanykind, eitherexpressedorimplied.Whileeveryprecaution hasbeentakeninthe preparationofthismanual,
Land Pride assumes no responsibility forerrors or omissions. Neither is any liability assumed fordamages resulting fromthe use of theinformation contained herein. Land
Pride reserves the right to revise and improve its products as it sees fit. This publication describes thestate of this product at thetime of its publication, and may not reflect
the product in the future. The illustrations in this manual are not intended for safe and proper assembly or disassembly of equipment. The illustrations are intended for
ordering parts only.
Land Pride is a registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
RTA10 & RTA15 Series Rotary Tillers 311-252M
Important Safety Information . . . . . . . . . . .1
Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1
Look For The Safety Alert Symbol . . . . . . . . . . . . . 1
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Introduction . . . . . . . . . . . . . . . . . . . . . . . .7
Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . 7
Terminology . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . 7
Serial Number Plate . . . . . . . . . . . . . . . . . . . . . 7
Further Assistance . . . . . . . . . . . . . . . . . . . . . . 7
Section 1 Assembly and Set-Up . . . . . . . .8
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . 8
Hitch and Driveline Guard . . . . . . . . . . . . . . . . . . . 9
Leg Stand Assembly . . . . . . . . . . . . . . . . . . . . . . . 9
Tractor Hook-Up . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Driveline Installation . . . . . . . . . . . . . . . . . . . . . . . 10
Checking Driveline Minimum Length . . . . . . . . 10
Checking Driveline Maximum Length . . . . . . . 11
Section 2 Operating . . . . . . . . . . . . . . . . .12
General Notes for Field Operations . . . . . . . . . . . 12
Operating Check List . . . . . . . . . . . . . . . . . . . . 12
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Operating Instructions . . . . . . . . . . . . . . . . . . . . . 13
Section 3 Adjustments . . . . . . . . . . . . . . .14
RTA10 Tiller Hitch Offset . . . . . . . . . . . . . . . . . . . 14
RTA15 Tiller Hitch Sideshift . . . . . . . . . . . . . . . . . 14
Drive Chain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Rear Deflector . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Skid Shoe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Section 4 Maintenance and Lubrication .17
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
Tine Replacement . . . . . . . . . . . . . . . . . . . . . . . .17
Driveline Protection . . . . . . . . . . . . . . . . . . . . . . .17
Clutch Run-In . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
Clutches With 8-Hex Head Socket Bolts . . . . .17
Clutches With 4-Tightening Nuts . . . . . . . . . . .17
Clutch Disassembly & Reassembly . . . . . . . . . . .18
Clutches With 8-Hex Head Socket Bolts . . . . .18
Clutches With 4-Tightening Nuts . . . . . . . . . . .19
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21
Driveline U-Joint . . . . . . . . . . . . . . . . . . . . . . .21
Driveline Shaft . . . . . . . . . . . . . . . . . . . . . . . . .21
Chaincase . . . . . . . . . . . . . . . . . . . . . . . . . . . .21
Bearing On Right End Of Rotor Shaft . . . . . . .22
Side Plug Gearbox . . . . . . . . . . . . . . . . . . . . .22
Top Plug Gearbox (10 Series) . . . . . . . . . . . . .22
Top Plug Gearbox (15 Series) . . . . . . . . . . . . .22
Section 5 Specifications and Capacities 23
RTA10 Series Rotary Tiller . . . . . . . . . . . . . . . . . .23
RTA15 Series Rotary Tiller . . . . . . . . . . . . . . . . . .23
Section 6 Features and Benefits . . . . . . .24
RTA10 Series Rotary Tiller . . . . . . . . . . . . . . . . . .24
RTA15 Series Rotary Tiller . . . . . . . . . . . . . . . . . .25
Section 7 Troubleshooting . . . . . . . . . . .26
Section 8 Appendix . . . . . . . . . . . . . . . . .27
Torque Values Chart . . . . . . . . . . . . . . . . . . . . . .27
Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29
Table of Contents