Filter
Top Products
7/01/05
17
Section 4 Operating Instructions
4400EX Heavy Duty Off Road Utility Vehicle 720-132M
Table of Contents
Fuel Indicator
Refer to Figure 4-5
#19 Fuel Gauge: The fuel gauge, located on the gas tank,
displays approximately how much fuel you have in
the fuel tank. Always park the vehicle on level ground
to get an accurate reading. The fuel tank is empty
when the fuel gauge needle points to E and full when
the needle points to F.
Figure 4-5
Steering
Refer to Figure 4-6
#20 Power Steering: The vehicle steers by pivoting about
the center swivel yoke with a hydraulic cylinder.
Figure 4-6
Seat Belts
Gondos equipped with a ROPS (Roll Over Protection
System) are also equipped with seat belts.
Seat Belts with ROPS reduce the risk of injury from
rollovers, collisions and being thrown from the vehicle. It is
the responsibility of the operator and passenger to decide
if their situation warrants using seat belts.
19
22080
IMPORTANT: Become familiar with the steering
capabilities of the Gondo before putting the vehicle into
service. Be certain to practice steering going forward
and backing up as it has a different feel than normal
front wheel steered vehicles.
21346
Power Steering
Hydraulic Cylinder
Center Swivel
Yoke
20
Pivot Point
!
WARNING
Lap belts should fit snugly and as low around the hips as
possible. Wearing seat belts high around the waist greatly
increases the chances of that person being injured in a
dangerous situation.
!
WARNING
Never use a lap belt for more than one person and never buckle
the lap belt to a buckle designed to receive the other lap belt.
Seat Belt Components
Refer to Figure 4-7
#21 Lap Belt: The lap belt is the belt that extends from the
retractor when pulled across your lap to be buckled.
It is located on the left side of the driver’s seat and
right side of the passenger’s seat.
Refer to Figure 4-8
#22 Buckle: Both operator and passenger buckles are
located between the two seats. It secures the lap belt
in place.
Figure 4-7
Figure 4-8
Seat Belt Operation
Pull the lap belt across your hips and insert its tongue into
the buckle until you hear it snap. Release the lap belt by
pressing the release button in the center of the buckle.
Guide the lap belt to its original position as it retracts to
keep it aligned and to prevent its tongue from striking and
damaging surfaces on the vehicle.
21
Tongue
22071
Retractor
22
Release
Button
22072