Hayward Pools H250FDP Swimming Pool Heater User Manual


  Open as PDF
of 16
 
12
SPRING START-UP – CONSULT A PROFESSIONAL:
1. Inspectandcleantheheater,beingsuretheheaterisfreeofleavesanddebrispriortostartup.
2. Besureinletandoutletpipingareproperlyattachedtotheheaterandthedrainvalveisclosed.
3. Turntheltrationsystempump“ON”andallowthesystemtorunlongenoughtopurgealltheair
fromthelines.
4. Turnthegassupplytotheheater“ON”.
5. Setthetemperaturecontrolusingthekeypadto“POOL”or“SPA”andadjustthesetpointtothe
desiredtemperaturesetting.
6. Ifoperatingdifcultiesareencountered,contactaqualiedservicecompanyforassistance.
ERROR CODES:
Figure5liststheerrorcodesthatmaybedisplayedontheheaterdisplayboard.
Contactaqualiedservicecompanyforassistance.
Code Description Information
bD
Internalfault/power-up
error
Oninitialtrialforignition.Automaticresetisimmediateoncethegasvalve
relaycheckresultsareacceptable.
bD
Gasvalvesensed
as“ON”error
Ifvalveisopenwhenitshouldbeclosedtheheaterwillshutdownandgointo
lockout.Blowerwilloperateuntilerrorconditioniscorrected.Automaticrestart
2minutesaftererroriscorrected.
bD
Gasvalvesensed
as“OFF”error
Ifvalveisclosedbutameissensedtheblowerwillrunfor5sthenstartanew
ignitionsequence.Iferroroccurs10timesduringacallforheatthecontrolwill
gointolockout.Automaticresetis60minutes.
bD Dataretrievalerror Ifcontrolinputdataiscorruptedtheheaterwillshutdownandgointolockout.
HF
Flamepresentwithgas
valve“OFF”error
Ifameissensedwiththegasvalveoffthecontrolwillgointolockout.The
blowerwillrununtilerrorconditioniscorrected.Whencorrected,controlwill
runblowerfor5sthenautomaticallyrestartafter2minutes.
PF
Electricalsupplywiring
error
Thiscodewilldisplayif120Vpolarityisreversed,lowvoltageisdetected,orif
thegroundpathisnotsufcient.Resetisimmediateaftererroriscorrected.
AO
Proverswitch
openerror
Iftheblowerproverswitchdoesnotcloseaftertheblowerstartsthecontrolwill
stoptheignitiontrialgointolockout.Theblowerwillcontinuetorun.Automat-
icresetisimmediateaftertheswitchcloses.
AO
Proverswitchopen
whenexpectedclosed
error
Iftheblowerproverswitchopensunexpectedlyduringoperationthecontrolwill
shutdownandattempttore-light.Iftheswitchdoesnotcloseaftertheblower
startsthecontrolwillgointolockoutwiththeblowerrunning.Automaticresetis
immediateaftererroriscorrected.
Figure5:ERROR CODES
 previous next