Filter
Top Products
10
2.5 WATTAGE REFERENCE GUIDE
Device . . . . . . . . . . . . . . . . . . . . . . .Running Watts
*Air Conditioner (12,000 Btu) . . . . . . . . . . . . . . . . .1700
*Air Conditioner (24,000 Btu) . . . . . . . . . . . . . . . . .3800
*Air Conditioner (40,000 Btu) . . . . . . . . . . . . . . . . .6000
Battery Charger (20 Amp) . . . . . . . . . . . . . . . . . . . . .500
Belt Sander (3") . . . . . . . . . . . . . . . . . . . . . . . . . . . .1000
Chain Saw . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1200
Circular Saw (6-1/2") . . . . . . . . . . . . . . . . . . .800 to 1000
*Clothes Dryer (Electric) . . . . . . . . . . . . . . . . . . . . .5750
*Clothes Dryer (Gas) . . . . . . . . . . . . . . . . . . . . . . . . .700
*Clothes Washer . . . . . . . . . . . . . . . . . . . . . . . . . . .1150
Coffee Maker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1750
*Compressor (1 HP) . . . . . . . . . . . . . . . . . . . . . . . .2000
*Compressor (3/4 HP) . . . . . . . . . . . . . . . . . . . . . . .1800
*Compressor (1/2 HP) . . . . . . . . . . . . . . . . . . . . . . .1400
Curling Iron . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .700
*Dehumidifier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .650
Disc Sander (9") . . . . . . . . . . . . . . . . . . . . . . . . . . . .1200
Edge Trimmer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .500
Electric Blanket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .400
Electric Nail Gun . . . . . . . . . . . . . . . . . . . . . . . . . . . .1200
Electric Range (per element) . . . . . . . . . . . . . . . . . .1500
Electric Skillet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1250
*Freezer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .700
*Furnace Fan (3/5 HP) . . . . . . . . . . . . . . . . . . . . . . . .875
*Garage Door Opener . . . . . . . . . . . . . . . . . . .500 to 750
Hair Dryer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1200
Hand Drill . . . . . . . . . . . . . . . . . . . . . . . . . . .250 to 1100
Device . . . . . . . . . . . . . . . . . . . . . . .Running Watts
Hedge Trimmer . . . . . . . . . . . . . . . . . . . . . . . . . . . . .450
Impact Wrench . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .500
Iron . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1200
*Jet Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .800
Lawn Mower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1200
Light Bulb . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100
Microwave Oven . . . . . . . . . . . . . . . . . . . . . .700 to 1000
*Milk Cooler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1100
Oil Burner on Furnace . . . . . . . . . . . . . . . . . . . . . . . .300
Oil Fired Space Heater (140,000 Btu) . . . . . . . . . . . . .400
Oil Fired Space Heater (85,000 Btu) . . . . . . . . . . . . . .225
Oil Fired Space Heater (30,000 Btu) . . . . . . . . . . . . . .150
*Paint Sprayer, Airless (1/3 HP) . . . . . . . . . . . . . . . .600
Paint Sprayer, Airless (handheld) . . . . . . . . . . . . . . . .150
Radio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50 to 200
*Refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .700
Slow Cooker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .200
*Submersible Pump (1-1/2 HP) . . . . . . . . . . . . . . . .2800
*Submersible Pump (1 HP) . . . . . . . . . . . . . . . . . . .2000
*Submersible Pump (1/2 HP) . . . . . . . . . . . . . . . . .1500
*Sump Pump . . . . . . . . . . . . . . . . . . . . . . . .800 to 1050
*Table Saw (10") . . . . . . . . . . . . . . . . . . . . .1750 to 2000
Television . . . . . . . . . . . . . . . . . . . . . . . . . . . .200 to 500
Toaster . . . . . . . . . . . . . . . . . . . . . . . . . . . .1000 to 1650
Weed Trimmer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .500
*Allow 3 times the listed watts for starting these devices.
Section 2 – Operation
Commercial-Industrial-Residential Portable Generator System
2.6 BEFORE STARTING THE
GENERATOR
Prior to operating the generator, engine oil and gasoline will need
to be added, as follows:
2.6.1 ADDING ENGINE OIL
NOTE: When adding oil to the engine crankcase in
the future, use only high quality detergent oil rated
with API service classification SF or SG SAE 30
weight. Use no special additives.
Select the oil’s viscosity grade according to the expected
operating temperature. Do not use SAE 10W-40.
• Above 40°F, use SAE 10W-30 or SAE 30.
• Below 40°F, use synthetic 5W-20 or 5W-30.
Although multi-viscosity oils (5W-30, 10W-30, etc.) improve
starting in cold weather, these multi-viscosity oils will result in
increased oil consumption when used above 32°F. Check your
engine oil level more frequently to avoid possible damage from
running low on oil.
• Place generator on a level surface.
• Clean area around oil fill and remove oil fill cap and dipstick.
• Wipe dipstick clean.
• Slowly fill engine with oil through the oil fill opening until it
reaches the full mark on the dipstick. Stop filling occasionally
to check oil level. DO NOT OVERFILL.
• Install dipstick. Install oil fill cap and finger tighten securely.
• Check engine oil level before starting each time thereafter.
ITEM PART # QTY. DESCRIPTION
66 0D6592 1 WINGNUT, AIRBOX
67 0D4511 1 PRECLEANER, AIR
68 0D9723 1 ELEMENT, AIR CLEANER
69 0E5302 1 STUD M6-1.0 X 73
70 0D4183 1 ADAPTOR, SPIT BACK
71 0D6327 1 GASKET, SPITBACK
72 0D2774B 1 BASE, AIRBOX (GT-990)
0E4870 1 BASE, AIRBOX (GT-760)
73 0D5125 1 SPRING, WINTER/SUMMER VALVE
74 0D2930 1 VALVE, SUMMER / WINTER
75 0D4612A 1 SNORKEL, AIR INTAKE
76 0D6143 1 TUBE, HEAT RISER 50.8 I.D.
77 0D2775 1 COVER, AIRBOX
78 0D5014A 1 KNOB, AIRBOX 17mm
79 0D5014B 1 KNOB, AIRBOX 95MM
80 049721 1 SCREW HHC M6-1.0 X 35
81 022097 1 WASHER LOCK M6-1/4
82 022473 1 WASHER FLAT 1/4
83 052857 4 NUT LOCK FLANGE M6-1.0
84 0D6021 4 STUD, METRIC
85 0C9093A 1 HOSE, BREATHER
86 0D4522 1 CONTROLLER ASSEMBLY
87 074908 2 SCREW HHTT M5-0.8 X 10
89 0E3398 1 ASSEMBLY, WIRE
90 0E2548 1 CARBURETOR (GT-990)
0E5077 1 CARBURETOR (GT-760)
91 0D4026 1 GASKET, CARB TO SPACER
(GT-990)
0D4024 1 GASKET, CARB/AIRBOX (GT-760)
92 048031C 4 CLAMP HOSE BAND 1/4
93 030340 12" HOSE ¼ ID
94 0D4023 1 GASKET, MANIFOLD TO CARB
(GT-990)
0D5282 1 GASKET, MANIFOLD TO CARB
(GT-760)
95 086061G 1 SLEEVING 1/2" I.D.
96 0D6313 1 FILTER, FUEL
97 070008 4 WASHER FLAT M8
98 070006 4 WASHER LOCK M8
99 049821 4 SCREW SHC M8-1.25 X 30
100 0C9911 1 MANIFOLD, INTAKE
101 051714 1 NUT HEX M3-0.5
102 0D5411 1 ROD, SUMMER / WINTER VALVE
103 0D5445 1 BUSHING, MINI CONTROL PANEL
104 0D5416A 1 KNOB, CONTROL SUMMER /
WINTER
105 0D5398 1 CHOKE ASSEMBLY
106 0E6043 2 SCREW TAPTITE M5-0.8 X 8 ZP
107 0D3432 1 PANEL, CONTROL FACE PLATE
108 045756 24 SCREW TAPTITE M6-1.0X 10
YELLOW CHROME
109 0D4767 1 SWITCH ROCKER
110 0D1142A 1 WRAPPER, LOWER CYLINDER 2
111 0D1143 1 WRAPPER, UPPER CYLINDER 2
112 0F1177 1 ASSEMBLY, GROUND WIRE
113 022097 4 WASHER LOCK M6-1/4
114 092079 4 SCREW TAPTITE M6-1.0 X 25 BP
ITEM PART NO#.QTY. DESCRIPTION
115 0F1338B 1 ASSY, IGN COIL W/DIODE NO ADV
116 0C4147 1 PUMP, IMPULSE
117 022264 2 WASHER LOCK M4
118 0D6142 2 SCREW PPHM M4-0.7 X 40
119 0D5399A 1 ELBOW, RUBBER 90 DEG.
120 0E7585 2 SPARKPLUG, CHAMPION RC14YC
121 0E4271 1 STARTER, DELCO REMY SD80
122 022129 3 WASHER LOCK M8-5/16
123 061906 2 SCREW HHC M8-1.25 X 85 G8.8
124 022145 1 WASHER, FLAT M8
125 045771 1 NUT, HEX M8-1.25 G8
126 0D1131 1 GUARD,FAN
127 0C3022B 1 HOUSING, BLOWER GASOLINE
COOLER
128 0C9763 4 NUT, GROMMET 1/4 PLUG
129 0C3034 1 NUT,HEX M24
130 0C3033 1 WASHER, M24
131 0C3032 1 PLATE, FAN
132 0A5992 2 WASHER SHAKEPROOF INT M8 SS
133 051754 2 SCREW HHC M8-1.25 X 12 G8.8
134 0C3031 1 FAN, NYLON
135 0E4997 1 ASSY,GROUND WIRE CONNECTOR
136 045756 4 SCREW TAPTITE M6-1X10 YELLOW
CHROME
137 0C3725A 1 FLYWHEEL ASSEMBLY
138 0C3016A 1 PLATE, BACKING GT990 WITH OIL
COOL
139 082774 1 KEY, WOODRFF 4 X 19D
140 0C3043 2 GASKET, MANIFOLD / PORT
141 0C9764 4 PLASTITE,1/4-15 X 3/4
142 0C3026 1 COOLER, OIL
143 0C7649 4 CLAMP HOSE .38-.87
144 0C9806 2 HOSE, 3/8" I.D. X 6" LONG
145 035461A 2 BARBED STR 1/4NPT X 3/8 WITH
VIBRA SEAL
146 070185B 1 OIL FILTER
147 0C7292 1 NIPPLE, 3/4"-16 UNF
148 0D3083 1 ASSEMBLY, OIL DRAIN HOSE
149 0C3025 1 SWITCH, OIL PRESS
150 0D4550 1 BRACKET, AIRBOX SUPPORT
151 0C3018 1 WRAPPER, UPPER CYLINDER 1
152 0C3019 1 WRAPPER, LOWER CYLINDER 1
153 046964A 1 BRASS ST ELBOW 1/4 NPT
154 0E0409 1 ASSY, ROD, GOV. STEPPER
MOTOR
155 0C8563 6 SCREW HHHC M6-1.0 X12
157 0D9784 2 NUT, LOCK HEX M3-0.5 (GT-990)
0E4869 2 NUT, HEX W/TOOTH WASHER M3-
0.5 (GT-760)
158 031879 1 WASHER FLAT #4 (GT-990)
0E4868 1 WASHER FLAT #4 (GT-760)
159 0D6098 1 SPACER, ROD (GT-760 ONLY)
160 0D6147 7 SCREW HHFC M6-1.0 X 10mm
161 0F1338A 1 ASSY, IGN COIL W/DIODE NO ADV
27
Section 7 — Exploded Views and Parts Lists
Commercial-Industrial-Residential Portable Generator System
GT-990 & GT-760 Engine (Page 2) – Drawing No. 0E8589E