Filter
Top Products
STORAGE
Immediately prepare your tractor for storage at the end of
the season or if the tractor will not be used for 30 days or
more.
...................... IIIIII III IIIII
i _ CAUTION: Never storethe tractor with
gasoline in the tank inside a building
where fumes may reach an open flame
or spark. Allow the engine to cool
before storing in any enclosure.
..................................... UnU/I
TRACTOR
Remove mower from tractor for winter storage,, When
mower is to be stored for a period of time, clean it thor-
oughly, remove all dirt, grease, leaves, etc. Store in a
clean, dry area.
• Clean entire tractor (See "CLEANING" inthe Customer
Responsibilities section of this manual),
• Inspect and replace belts, if necessary (See belt re-
placement instructions in the Service and Adjustments
section of this manual)_
• Lubricate as shown in the Customer Responsibilities
section of this manual.
° Be sure that all nuts, bolts and screws are securely
fastened. Inspect moving partsfor damage, breakage
and wear. Replace if necessary.
• Touch up all rusted or chipped paint surfaces; sand
lightly before painting.
BATTERY
• Fully charge the batteryfor storage,
• After a period of time in storage, battery may require
recharging_
. To help prevent corrosion and power leakage during
long periods of storage, battery cables should be
" _ O
d_sconnected and battery cleaned thoroughly (see q"
CLEAN BATTERY AND TERMINALS" in the Cus-
tomer Responsibilities section of this manual).
° After cleaning, leave cables disconnected and place
cables where they cannot come in contact with battery
terminals.
• Be sure battery drain tube is securely attached,
° If battery is removed from tractor for storage, do not
store battery directly on concrete or damp surfaces°
ENGINE
FUEL SYSTEM
IMPORTANT: IT IS iMPORTANT TO PREVENT GUM
DEPOSITS FROM FORMING 1N ESSENTIAL FUEL
SYSTEM PARTS SUCHAS CARBURETOR, FUEL FILTER,
FUEL HOSE, OR TANK DURING STORAGE. ALSO,
EXPERIENCE INDICATES THAT ALCOHOL BLENDED
FUELS (CALLED GASOHOL OR USING ETHANOL OR
METHANOL) CAN ATTRACT MOISTURE WHICH LEADS
TO SEPARATION AND FORMATION OF ACIDS DURING
STORAGE. ACIDIC GAS CAN DAMAGE THE FUEL
SYSTEM OF AN ENGINE WHILE IN STORAGE
° Drain the fuel tank.
• Start the engine and let it run until the fuel lines and
carburetor are empty,
= Never use engine or carburetor cleaner products in the
fuel tank or permanent damage may occur_
° Use fresh fuel next season.
NOTE: Fuel stabilizer is an acceptable alternative in
minimizing the formation of fuel gum deposits during stor-
age. Add stabilizer to gasoline in fuel tank or storage
container° Always follow the mix ratio found on stabilizer
container. Run engine at least 10 minutes after adding
stabilizer to aIlow the stabilizer to reach the carburetor. Do
not drain the gas tank and carburetor if using fuel stabilizer.
ENGINE OIL
Drain oil (with engine warm) and replace with clean engine
oil_ (See "ENGINE" in the Customer Responsibilities
section of this manual),
CYLINDERS
° Remove spark plug(s),,
° Pour one ounce of oil through spark plug hole(s) into
cylinder(s),
= Turn ignition key to"START" positionfor a few seconds
to distribute clio
° Replace with new spark plug(s)_
OTHER
• Do not store gasotine from one season to another,
• Replace your gasoline car] if your can starts to rusL
Rust andtor dirt in your gasoline will cause problem&
= If possible, store your tractor indoors and cover it to
give protection from dust and dirt,
• Cover your tractor with a suitable protective cover that
does not retain moisture Do not use plastic. Plastic
cannot breathe which allows condensation to form and
will cause your tractor to rusL
IMPORTANT: NEVER COVER TRACTOR WHILE ENGINE
AND EXHAUST AREAS ARE STILL WARM.
28