21se c t i O n 6 — Ma i n t e n a n c e & ad j u s t M e n t s
Turn the reservoir cap counterclockwise to re-move, then 2.
If necessary to add oil because of some type of leakage, use
tighten.
Battery
CALIFORNIA PROPOSITION 65 WARNING!
contain lead and lead compounds, chemicals known
reproductive harm. Wash hands after handling.
The battery is sealed and is maintenance-free. Acid levels cannot
be checked and fluid can not be added.
Always keep the battery cables and terminals clean and
free of corrosive build-up.
After cleaning the battery and terminals, apply a light coat
of petroleum jelly or grease to both terminals.
CAUTION: If removing the battery for cleaning,
When re-installing the battery, always connect the
connected to the correct terminals; reversing them
alternating system.
Battery Storage
When storing the tractor for extended periods, disconnect
the negative battery cable. It is not necessary to remove
the battery.
All batteries discharge during storage. Keep the exterior 2.
of the battery clean, especially the top. A dirty battery will
discharge more rapidly.
The battery must be stored with a full charge. A discharged
battery can freeze sooner than a charged battery. A fully
charged battery will store longer in cold temperatures than hot.
Recharge the battery before returning to service. Although 4.
the tractor may start, the engine charging system may not
fully recharge the battery.
If exchanging tanks, be sure to use cylinders that contain 7.
patented specifically for lawn care use as a vapor-delivery
system.
NOTE:
section for information on new, previously un-filled tanks.
To re-install the tank, reverse the above instructions 8.
but make sure the alignment pin fits into the slot on the
bottom of the cylinder valve guard.
WARNING!
installing tank. Leaks must never be checked with a
flame. Always check for seal compromise with a
spray bottle filled with soapy water and look for
bubbles.
Air Cleaner
Spark Plug(s)
The spark plug should be cleaned and the gap reset once a
type and gap specifications.
Hydrostatic Transmission
Your zero turn tractor is equipped with dual integrated
hydrostatic pumps/transaxles that are sealed and are
transmission oil expansion reservoir. Under normal operating
conditions, the oil level in the expansion reservoir does not need
to be checked and no additional oil is needed. If checking the
reservoir oil level, proceed as follows:
WARNING!
starting the tractor when the transmission oil is fully
cooled.
cap and the area around the cap to prevent debris from
Figure 6-2
