Filter
Top Products
-- 5 --
CHECK FOR LOOSE
FASTENERS AND PARTS
S
Spark Plug Boot
S
Air Filter
S
Housing Screws
CHECK FOR DAMAGED OR
WORN PARTS
Contact an Authorized Service Dealer for re-
placement of damaged or worn parts.
S
Throttle Lever -- Ensure throttle lever func-
tions properly bymoving thethrottle leverto
the STOP position. Make sure engine
stops; then restart engine and continue.
S
Fuel Tank -- Discontinue use of unit if fuel
tank shows signs of damage or leaks.
INSPECT AND CLEAN UNIT AND
DECALS
S
After each use, inspect complete unit for
loose or damaged parts. Clean the unit
using a damp cloth with a m ild detergent.
S
Wipe off unit with a clean dry cloth.
CLEAN AIR FILTER
Screw
Air Filter
Air Filter Cover
Cleaning the air f ilter:
A d irty air filter decreases engine perform-
ance and increases fuel consumption and
harmful emissions. Always clean after every
5 hours of operation.
S
Clean the cover and the area around it to
keep debris from falling into the carbure-
tor chamber when the cover is removed.
S
Remove parts as illustrated.
NOTE:
Do not clean filter in gasoline or
other flammable solvent. Doing so can
create a fire hazard or produce harmful
evaporative emissions.
S
Wash the filter in soap and water.
S
Allow filter to dry.
S
Apply a few drops of oil to the filter;
squeeze filter to distribute oil.
S
Replace parts.
REPLACE SPARK PLUG
Replace spark plug each year to ensure the
engine starts easier and runs better. Set
spark plug gap at0.025 inch. Ignition timing is
fixed, nonadjustable.
S
Twist, then pull off spark plug boot.
S
Remove spark plug from cylinder and dis-
card.
S
Replace with Champion RCJ-7Y spark
plug and tighten with a 3/4 inch socket
wrench (10--12 ft/lbs).
S
Reinstall the spark plug boot.
INSPECT MUFFLER AND SPARK
ARRESTING SCREEN
WARNING:
The muffler on this
product contains chemicals known to the
State of California to cause cancer.
As your unit is used, carbon deposits build up
on the muffler and spark arresting screen and
must be removed to avoid creating a fire haz-
ard or affecting engine performance.
For normal homeowner use, the muffler and
spark arresting screen will not require any
service. After 50 hours of use, we recom-
mend that your muffler be serviced or re-
placed by your Authorized Service Dealer.
SERVICE
We recommend al l service and adjustments
not listed in this manual be performed by an
Authorized Service Dealer.
CARBURETOR ADJUSTMENTS
Your carburetor is equipped with limiter caps.
Damage will occur if y ou tur n the needles be-
yond the limiter caps. Car bur etor adjustment is
a complicated task. We recommend that you
take your unit to a n Authorized Ser vice D ealer.
STORAGE
WARNING:
Perform the following
steps after each use:
S
Allow engine to cool, and secure the unit
before storing or transporting.
S
Store unit and fuel in a well ventilated
area where fuel vapors cannot reach
sparks or open flames from water heat-
ers, electric motors or switches, furnaces,
etc.
S
Store unit with all guards in place. Posi-
tion unit so that any sharp object cannot
accidentally cause injury.
S
Store unit and fuel well out of the reach of
children.
NEED AS SISTANCE?
NEED ASSISTANCE?
Call 1-800-554-6723 for assistance.
NEED SERVICE PART?
Contact your dealer or call 1-800-554-6723.