Filter
Top Products
l
PAGE 20 — MVC77 PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #4 (1/14/11)
Inspection and Maintenance Service Tables.
1. To make sure your plate compactor is always in good
working condition before using, carry out the maintenance
inspection in accordance with Tables 4 through 6.
KCEHCENIGNE.5ELBAT
)launaMenignEetarapesees,sliatedroF(
metI noitarepOfosruoH
leufroliofoegakaeL )yadyreve(sruoh8yrevE
sdaerhtgninetsaffossenthgiT )yadyreve(sruoh8yrevE
dnakcehclioenignE
tnemhsinelper
yreve(sruoh8yrevE
.xamdeificepsothsinelpeR()yad
)level
tnemhsinelperlioenignE
001yreveneht,sruoh02tsriftA
sruoh
gninaelcrenaelcriA sruoh05yrevE
.6ELBAT
retemaiD)mc/gk.ni(EUQROTGNINETHGIT
lairetaM
mm6 mm8 mm01 mm21 mm41 mm61 mm81 mm02
T4 07 051 003 005 057 001,1 004,1 000,2
T8-6 001 052 005 008 003,1 000,2 007,2 008,3
T11 051 004 008 002,1 000,2 009,2 002,4 006,5
* )mm01(007~056)mm8(053~003)mm6(001
)munimulafositrap-retnuocesacnI(*
)dednahthgirllaeraenihcamsihthtiwesunisdaerhT(
,tlobhcaenodekramsilairetamfoytilauqdnalairetaM
.wercsdna
Engine Oil Replacement:
1. Replace engine oil, in first 20 hours of operation and every
100 hours afterwards.
2. Oil may be drained more easily when it is warm after
operation (For more details, see separate HONDA or ROBIN
Owner's Manual).
3. When changing the engine oil, thenold oil can be drained
by removing the oil filler cap, and un-screwing the engine
oil drain plug located at the base of the engine.
4. Remember to refill engine crankcase with the recommended
type of oil as listed in Table 3.
Check for leakage of fuel or oil.
Remove soil and clean the bottom of compaction plate.
Check engine oil, see page 13.
Check for loose screws including tightness. See Table 6
below (tightening torque ), for retightening:
Daily Service
NOITCEPSNIENIHCAM.4ELBAT
metI noitarepOfosruoH skrameR
)kcehcgnitratS(
yreve(sruoh8yrevE
)yad
tsolrodenesooL
swercs
yreve(sruoh8yrevE
)yad
trapynafoegamaD
yreve(sruoh8yrevE
)yad
gnillortnocfonoitcnuF
trapmetsys
yreve(sruoh8yrevE
)yad
kcehcliorotarbiV sruoh001yrevE .91egapeeS
liorotarbiV
tnemecalper
sruoh002yrevE .91egapeeS
kcehc)hctulc(tleb-V ruoh002yrevE .91egapeeS
MAINTENANCE
Inspection and other services should
always
be carried out
on hard and level ground with the engine shutdown.
CAUTION
These inspection intervals are for operation under normal
conditions. Adjust your inspection intervals based on the
number hours plate compactor is in use, and particular
working conditions.
CAUTION
Fuel piping and connections should be replaced every 2
years.
CAUTION