Filter
Top Products
601656_1108
41
This section contains sources of additional literature
concerning your tractor. Literature should be ordered from
your Hustler dealer or direct from indicated source.
Parts Manuals
If you would like to order a Parts Manual for a particular
tractor, the Hustler part number for that manual is listed in
the following chart. Please contact your Hustler dealer to
order the manual.
PRODUCT LITERATURE
When storing the unit at the the end of the mowing season, the following
steps should be taken to ensure readiness for the next mowing season.
1. Remove all grass, dirt, and trash from tractor and mower. Clean
tractor and mower and touch up all scrapes with Hustler spray paint.
2. Replace air filter element.
3. Check thoroughly for any worn or damaged parts that need
replacing and order them from your dealer.
4. Thoroughly lubricate machine, according to lubrication instructions.
5. Check hydraulic oil level. Add oil if necessary or change oil and
filter if not done in last 500 hours. Refer to Maintenance section.
6. Block tractor up so weight is off tires.
NOTE: Do not deflate tires.
7. Perform separate engine and battery preparation as listed below.
8. Store tractor in a clean, dry place.
Preparation of engine for storage
When engine is to be unused for long periods, proceed as follows:
1. Run engine for a minimum of 15 minutes.
2. Drain oil from crankcase while engine is still warm.
3. Refill with fresh oil of proper viscosity.
4. Drain fuel tanks.
5. Remove and replace fuel filter.
6. Clean exterior surface of engine. Spread a light film of oil over any
exposed metal surfaces of engine that are subject to corrosion.
7. Check oil filler cap and fuel tank cap to make certain they are
securely in place.
Preparation of batteries for storage
When the machine is to be unused for long periods, it is best to
disconnect the batteries and remove them from the unit. At this time
perform the following battery maintenance:
1. Clean battery
2. Check the electrolyte level
3. Charge the battery, if necessary
4. Store battery in a cool, dry place (do not expose to freezing
temperatures)
5. Always keep the battery fully charged. (Especially important to
prevent battery damage when the temperature is below 32F.)
New season preparation
Before starting the tractor following post season storage, the following
servicing is required:
1. Clean tractor, removing trash and dirt accumulation.
2. Check engine oil, hydraulic oil and coolant levels.
3. Fill fuel tanks with fresh fuel. Bleed fuel system as outlined in
Maintenance section. Run machine at half speed for 5 minutes,
checking operation of steering control lever. Stop engine and check
for oil leaks, loose fittings and so forth.
WARNING: At start of new season always check that fresh
oil and coolant have been added to machine. If oil and
coolant are drained at season’s end and not replaced, engine
damage will result.
4. Tighten any bolts that have loosened and make sure all hair pins,
cotter pins and clevis pins are in place.
5. Install all safety shields and review safety precautions listed in this
manual.
6. Check and inflate tires to 8-12 psi (55-83
KPa).
7. Install fully charged batteries and attach the battery cables.
STORAGE
Parts
Model Manual List
Model Number P/N Price
Hustler Z XR7 927723, 927731, 927749, 927756, 106567 $22.50
927772, 927798, 927806, 927814
Hustler Z XR7 927723 A/B, 927749 A/B, 927756 A/B, 108602 $22.50
927772 A/B, 927798 A/B, 927806 A/B,
927814 A/B, 928432, 928853 A/B,
928861 A/B
Super Z XR7 927467, 927624, 927673, 927681, 106575 $22.50
927848, 927855, 927871, 927889,
927897, 927913, 927921, 927939,
927947, 927970, 927988, 927996,
928002, 928010, 928028, 928036,
928044, 928051, 928069
Super Z XR7 927467, 927624, 927673, 927681, 108603 $22.50
927848 A/B, 927855 A/B, 927871 A/B,
927889 A/B, 927897 A/B, 927913 A/B,
927921 A/B, 927939 A/B, 927947 A/B,
927970 A/B, 927988 A/B, 928010 A/B,
928028 A/B, 928036 A/B, 928044 A/B,
928051 A/B, 928069 A/B, 928879 A/B,
928887 A/B/HTB, 928895 A/B,
928911 A/B, 928929, 928937
Hustler Z Diesel 928606 A/B, 928614 A/B, 928622 A/B, 109706 $22.50
Shibaura engine 928648, 928655
ATZ XR7 928226, 928234 107906 $22.50