Exmark Cd42cd, Cd48cd Lawn Mower User Manual


 
11
n) Re-install the seal guards over the wheel hub and insert wheel into caster fork.
Re-install caster bolt and tighten nut fully.
IMPORTANT: To prevent seal and bearing damage, check the bearing
adjustment often. Spin the caster tire. The tire should not spin freely (more
than 1 or 2 revolutions) or have any side play. If the wheel spins freely, adjust
torque on spacer nut until there is a slight amount of drag. Re-apply thread
locking adhesive.
c) Lubricate switch actuator rod with spray type lubricant or light oil.
4.2.7 Change gearbox oil:
Change oil in all 3 gearbox housings after first 50 hrs of operation. Check
every 100 hours thereafter. Add oil as needed until level with oil drain plug.
a) Stop engine, wait for all moving parts to stop, and remove key.
b) Place unit on a level surface.
c) Remove the gearbox and drive shaft assembly from the mower deck. Retain
hardware for re-use.
d) Remove the large oil drain plug on the front of each of the 3 gearboxes and drain
oil. See Figure 9.
e) Remove small magnetic plugs and wipe away any material accumulated on the
plugs. See Figure 9.
FIGURE 9
GEARBOX OIL DRAIN LOCATIONS
f) Apply a Teflon pipe sealant to all small magnetic plugs and re-install into the
gearbox.
g) Re-install the gearbox and drive shaft assembly to the mower deck.
h) Fill gearbox with Mobil 1 75W-90 gear lube oil until level with oil drain plug.
NOTE: Mower deck should remain level to the ground when filling gearbox with oil.
Do not fill gearbox with deck raised in the service position.
i) Apply a Teflon pipe sealant to the 3 large oil plugs and re-install into the gearbox.
4.2.8 Thread locking adhesives such as “Loctite 242” or “Fel-Pro, Pro-Lock Nut Type” are
used on the following fasteners:
a) Caster wheel spacer nuts.
4.3 ADJUSTMENTS
IMPORTANT: Disengage PTO, shut off engine, wait for all moving parts to stop, and
remove key before servicing, cleaning, or making any adjustments to the unit.
4.3.1 Cutting Height Adjustment
:
a) Stop engine, wait for all moving parts to stop, and remove key.
b) Move cotter pins on four deck support pins to proper hole for height of cut
desired.