Filter
Top Products
...... SERVICE AND ADJUSTMENTS
o
ENGINE SPEED
CAUTION: ENGINE SPEED WAS PROPERLY AD-
JUSTED AT THE FACTORY AND SHOULD RE-
QUIRE NO ADDITIONAL ADJUSTMENT. DO NOT
ATTEMPT TO CHANGE ENGINE SPEED. IF YOU
BELIEVETHE ENGINE ISRUNNING TOO FAST OR
TOO SLOW, TAKE YOUR GENERATOR TO
AUTHORIZED SERVICE (3ENTER FOR REPAIR
AND ADJUSTMENT. CHANGING ENGINE GOV-
ERNED SPEED WILLVOIDrENG1NE WARRANTY.
Your generator runs at a constant speed. This constant
operating speed is maintained by a mechanical, flyv_ight
type, fixed speed governor._ DO NOT try to adjust the
governed speed setlJngfor the following reasons:
• High engine speeds are dangerous and increase the
risk of personal injury or damage to equipment,
• Lowengine speeds impose a heavy loadon the engine
when sufficient engine power is not available and may
shorten engine life.
The generator will supply correct rated AC frequenm¢
and voltage onlyatthe proper speed. Some connected
electrical devices could be damaged by incorrect fre-
que ncy andior voltage.
ADJUSTING THE CARBURETOR
The carburetor of your generator set is preset atthe factory.
DO NOT TAMPER WITH THE CARBURETOR as this will
void the warranty for the emission con_'ol system. If your
generator is to be used at an altitude above 5,000 feet,
consult with a Sears Authorized Service Facility regarding
high altitude jet_ng changes.
STORAGE
The generator should be stared at least once every seven
days and allowad to run at least 30 minutes. If this cannot
be done and you must store the unitfor more than 30days,
use me following information as a guide to prepare it for
storage.
STORAG E INSTR UCTIONS
WARNING: NEVER STORE ENGINE WITH FUELtN
THE TANK INDOORS OR IN ENCLOSED, POORLY
VENTILATED AREAS, WHERE FUMES CAN
REACH AN OPEN FLAME SPARK ORPILOTLIGHT
AS ON A FURNACE, WATER HEATER, CLOTHES
DRYER OROTHER GAS FURNACE,
ENGINE
• Run engine for about five minutes to warm it.
NOTE: lfyou did use "gasohol," drain fuel tank, then run
engine until engine stops from lack of fuel.
I A WARNING: DRAIN FUEL INTO APPROVED CON-
Ait
TAINER OUTDOORS, AWAY FROM OPEN FLAME.
BE SURE ENGINE IS COOL.
®
NOTE: Using a fuel additive such as Sears Craftsman
Fuel Stabilizer, or an equivalent, will prevent gum deposits
from forming in _e generator's fiJel system.
o While engine is still warm° drain oil from crankcase.
Refill with fresh oil. See BEFORE STARTING EN-
GINE on Page 5 for oil recommendations.
• Remove spark plug and pour about I ounce (30ml) of
engine oil into cylinder, Crank slov_y to distIibute oil.
CAUTION: AVOID SPRAY FROM SPARK PLUG
HOLE WHEN CRANKING ENGINE SLOWLY.
• Install spark plug. Do not connect spark plug wire.
o Clean dirt, oil and grease from cylinder, cylinder head,
fins, blower housing, rotating screen and muffler area.
GE NE RATOR
= Clean the generator as outlined on Page 7 (_Fo Clean
the Generator').
• Check that cooling air slots and openings on generator
are open and unobstructed.
OTHER STORAGE TIPS
• DO not store gasoline from one season to another.
e Replace your gasoline can if it starts to rust. Rust
and/or dirt in your gasoline can cause problems when
you use it with this unit.
o Store in clean and dry area.
DANGER; STORAGE COVER IS FLAMMABLE. DO
NOT PLACE THE STORAGE COVER OVER A HOT
GENERATOR. LETTHE UNIT COOL FOR A SUFFI-
CIENT TIME BEFORE PLACING THE COVER ON
THE UNIT. tF YOU PLACE THE COVER ON THE
UN1T BEFOREGENERATOR ISCOOL,THE COVER
COULD START ON FIRE.
9