Filter
Top Products
Figure 9 - 120 VAC, 30 Amp Receptacle
Use this receptacle to operate 120 Volt AC, 60 Hz, single phase
loads requiring up to 3600 watts (3.6 kW) of power at 30 Amps.
The outlet is protected by a 30 Amp push-to-reset circuit breaker.
2.2.4 120/240V AC, 30 AMP RECEPTACLE
Use a NEMA L14-30 plug with this receptacle. Connect a suitable
4-wire grounded cord set to the plug and to the desired load. The
cord set should be rated for 250 Volts AC at 30 Amps (or greater).
Figure 10 - 120/240 VAC, 30 Amp Receptacle
Use this receptacle to operate 120 Volt AC, 60 Hz, single phase
loads requiring up to 3600 watts (3.6 kW) of power at 30 Amps
or 240 Volt AC, 60 Hz, single phase loads requiring up to 7200
watts (7.2 kW) of power at 30 Amps. The outlet is protected by
two 30 Amp push-to-reset circuit breakers.
2.2.5 12 VOLT DC, 10 AMP RECEPTACLE
This receptacle allows you to recharge a 12 Volt automotive or
utility style storage battery with the battery charge cables
provided. This receptacle can not recharge 6 Volt batteries and
can not be used to crank an engine having a discharged battery.
See the section "Charging a Battery" (page 12) before attempting
to recharge a battery.
Figure 11 - 12 Volt DC, 10 Amp Receptacle
2.2.6 120/240 VOLT AC, 50 AMP RECEPTACLE
Use a NEMA 14-50 plug with this receptacle. Connect a 4-wire
cord set rated for 250 Volts AC at 50 Amps to the plug.
Figure 12 - 120/240 VAC, 50 Amp Receptacle
Use this receptacle to operate 120/240 Volt AC, 60 Hz electrical
loads requiring up to 12,000 watts (12.0 kW) of power. This
receptacle is protected by a 50 Amp 2-pole circuit breaker.
8
Section 2 – Operation
Commercial-Industrial-Residential Portable Generator System
29
Section 7 — Exploded Views and Parts Lists
Commercial-Industrial-Residential Portable Generator System
Generator – Drawing No. 0D4488-E
ITEM PART NO. QTY. DESCRIPTION
1 0C6934 1 ADAPTOR, ENGINE
2 0D2123 1 STATOR 12.5KW
0D2134 STATOR 15KW
3 0D21320SRV 1 ASSEMBLY, ROTOR WITH FAN
12.5KW
0D21330SRV 1 ASSEMBLY, ROTOR WITH FAN
15KW
4 0C6043B 1 CARRIER, REAR BEARING
5 0D2492 1 EXHAUST MANIFOLD
6 0D2726 1 MUFFLER
7 0C4138 2 GASKET, EXHAUST
8 0D3547 1 COVER, ALTERNATOR AIR IN
9 031971 1 BEARING
10 0C3168 3 5/16 SPECIAL LOCK WASHER
11 0D1838 1 SCREW IHHC 3/8-24 X 15.50 G5
12 0D3549 4 SCREW IHHC M8-1.25 X 400 G8.8
13 0C7038E 1 BRACKET, ALT MOUNTING
14 032712 4 SCREW HHTT #10-32 X 1.75
15 0D4662 1 SCREW HHTT M8-1.2 X 20
16 0C7038D 1 ENGINE MOUNTING PLATE
17 0C7758 6 RUBBER MOUNT
18 0388050AF0 1 BATTERY CABLE, BLACK
19 0C2417A 1 EARTH STRAP 3/8X 3/8
20 082121C 1 CLIP-J VINYL COAT .625 ID
21 066386 1 ASSEMBLY, BRUSH HOLDER
22 0C2824 1 SCREW TAP-R #10-32 X 9/16
23 0A2038 1 WASHER FLAT 3/8 ZINC
ITEM PART NO. QTY. DESCRIPTION
24 022237 5 WASHER LOCK 3/8
25 022511 4 SCREW HHC 3/8-16 X 1-1/4 G5
26 022131 4 WASHER FLAT 3/8-M10 ZINC
27 051731 4 SCREW HHC M8-1.25 X 50 G8.8
28 022145 21 WASHER FLAT 5/16 ZINC
29 049820 4 NUT LOCK HEX M8-1.25 NYLON
INSERT
30 079246 5 SCREW HHC M6-1.0 X 16 WITH
LOCK WASHER
31 022129 18 WASHER LOCK M8-5/16
32 022259 12 NUT HEX 5/16-18 STEEL
33 059637 2 SCREW TAPTITE 3/8-16 X 3/4 BP
34 0D5100 1 SHIELD, MUFFLER HEAT
35 0D5823 1 U-BOLT & SADDLE
36 0C8565 4 SCREW SHC M8-1.25 X 18
37 0D5833 1 PANEL, MUFFLER BOX BACK
38 0D5834 1 PANEL, MUFFLER BOX END
39 090388 3 SCREW HHTT M6-1.0 X 12
40 022473 5 WASHER FLAT 1/4
41 N/A - NOT USED
42 0D5133 1 SPARK ARRESTOR SCREEN
43 0D5133A 1 RETAINER, SPARK ARREST
SCREEN
44 045764 1 SCREW HHTT M4-0.7 X 8
45 0D6214 1 SHIELD, RUBBER MOUNT
46 066849 2 SCREW HHTT M5-0.8 X 16