Agri-Fab 45-02114 Spreader User Manual


  Open as PDF
of 12
 
5
FIGURE 2
FIGURE 3
2. Assemblethetwohitchbracestotheinsideofthehopper
frame,oneoneachside,usingtwo1/4"x1-1/2"hex
bolts(A)andtwo1/4"nylocknuts(D).DO NOT TIGHTEN
YET.Seegure2.
3. Removethenutfromthemiddleboltinthecrossover
tubeandshaftsupportplate.Leavetheboltinplace.
Seegure2.
4. Assemblethehitchtubeontothemiddleboltandsecure
itwiththesamenutyouremoved.DO NOT TIGHTEN
YET.Seegure2.
IMPORTANT:Thehitchtubemustattachtothesideofthe
crossovertubeoppositetheshaftsupportplate.
5. Assemblethetwohitchbracestothehitchtubeusinga
1/4"x1-1/2"hexbolt(A)anda1/4"nylocknut(D).DO
NOT TIGHTEN YET.Seegure2.
6. Tighten thenutsandboltsfasteningthehitchbraces
tothehopperframeandthehitchtube,thentighten
the middle lock nut fastening the hitch tube to the
crossovertube.DO NOT COLLAPSE TUBES WHEN
TIGHTENING.
(A) 1/4" x 1-1/2"
HEX BOLTS
(D) 1/4"
NYLOCK
NUTS
CROSSOVER
TUBE
HITCH BRACE
HITCH
TUBE
SHAFT
SUPPORT
PLATE
MIDDLE
NUT
MIDDLE BOLT
HITCH BRACE
7. Selecttheendoftheaxlewithnocrosshole.Assemble
aspacer(L),a5/8"atwasher(G),awheel(airvalve
facingout)andthenanother5/8"atwasher(G)onto
theaxle.Seegure3.
8. Installahubcap(Q)bytappingitcarefullyontotheaxle
withahammer.Seegure3.
(L) SPACER
(G) 5/8" DIA.
FLAT WASHER
(G) 5/8" DIA.
FLAT WASHER
(Q) HUB CAP
AIR VALVE
ENGLISH
FIGURE 4
9. Selecttheendoftheaxlecontainingthecrosshole.
Assembleaspacer(L),a5/8"atwasher(G),awheel
(airvalvefacingout)andthenanother5/8"atwasher
(G)ontotheaxle.Insertthe5/32"x2"cotterpin(I)
throughthewheelhubandtheaxleandthenspread
theendsofthepin.Seegure4.
10.Installahubcap(Q)bytappingitcarefullyontotheaxle
withahammer.Seegure4.
(I) 5/32" x 2"
COTTER PIN
AIR VALVE
(L) SPACER
(G) 5/8" DIA.
FLAT WASHER
(Q) HUB CAP
 previous next