Raypak 402B Swimming Pool Heater User Manual


 
Catalog No.: 6000.312D Effective: 8-15-08 Replaces: 2-1-08
Job:
Engineer:
Contractor:
Prepared By: Date:
Model: Indoor/Outdoor: MBTUH Input:
Sealed Combustion Chamber
100% Factory Fire Tested
Efficiency: 85%
Minimum Non-condensing Inlet Temperature: 105°F
Thermal Shock Proof Heat Exchanger
Limited Twenty-year Thermal Shock Warranty
Limited Five-year Heat Exchanger Warranty
Diagnostic Center with Fault History
PolyTuf Powder Coated Cabinet
No Combustible Floor Shield Required
Fan-assisted
Non-ferrous Bypass
Patented Burner Security Blanket
Heat Exchanger
Bronze Headers
ASME Inspected and Stamped
160 PSIG Working Pressure
National Board Approved
Cupro Nickel Finned Tubing
ASME Steel Tube Sheet
Silicone High Temp O-Rings
125 PSIG ASME Pressure Relief Valve
Temperature and Pressure Gauge
Water Connections
Left – Standard
Right – Option A-6
Bronze Pump, 1/3 HP, 120V, 60Hz
Non-Ferrous Pool Bypass Assembly
with Automatic Control
Controls
120V, 60Hz, 1 Power Supply
120/24V 60Hz Transformer
100% Shut-off/Lockout
Hot Surface Ignition
Remote Flame Sensor
High Limit Control, Auto Reset
On/Off Power Switch
Manual Shut-off, Front-mounted
Flow Switch
Blocked Vent Pressure Switch
Combustion Air Proving Switch
Economaster Pump Time Delay
Poolstat
Gas Train
Gas Pressure Regulator
Safety Shut-off Valve
Firing Control Valve
On/Off Firing
Fuel
Natural Gas
Propane Gas
Design Certified ANSI Z21.56/
CSA 4.7
Burner
Ultra-low NOx:
Less Than 30 PPM
Construction
Indoor/Outdoor Construction
Enclosed Front Controls
Venting
Vent Location
Top – Standard
Rear – Option D-14
Vent Termination Cap
Outdoor – Option D-11
Indoor, Horizontal –
Option D-15
Indoor, Vertical (by others)
Combustion Air
In-Line Filter Kit (TruSeal
only) – Option D-17
Air Intake Elbow –
Option D-16
Options
C-6 Ignition Module, Manual Reset
D-21 TruSeal™ Direct Vent
F-10 Low Water Cut-Off, Remote
Probe
I-1 High Limit Control, Auto Reset
S-1 Low Gas Pressure Switch,
Manual
S-2 High Gas Pressure Switch,
Manual
X-1 SureRack™ Kit
X-2 SureRack Add-on
Regulatory Agency Requirements
G-1 CSD-1
Hi Delta
®
- Type P
Commercial Pool Heaters
Models 302B & 402B
L
W