Pentair Energy Master Swimming Pool Pump User Manual


 
HYDROPUMP
®
AND
ENERGY MASTER
HYDROPUMP
®
TWO SPEED POOL AND SPA PUMP
INSTALLATION, OPERATION
& SERVICE MANUAL
TROUBLE GUIDE
THE FOLLOWING ARE SOME COMMON CAUSES OF PROBLEMS THAT MAY ARISE:
PROBLEMS POSSIBLE CAUSES & SOLUTIONS
A. PUMP WILL 1. Make sure pool water is midway of skimmer opening.
NOT PRIME: 2. Make sure strainer basket is not clogged.
3. Make sure strainer basket is positioned properly!
4. Tighten lid down snugly.
5. Make sure strainer pot is full of water.
6. TIghten all fittings and seal all joints on suction side.
7. Clean skimmer and pump strainer baskets.
8. Remove pump lid and check for clogging.
9. Open all valves in return and suction lines.
10. Remove and replace pump seal if needed.
11. Check voltage at pump to be sure it is same as motor specs.
B. LOW FLOW 1. If filter gauge reads high.
a. Filter is dirty.
b. Clogged return lines.
2. If filter pressure gauge reads low.
a. Pump or skimmer strainer basket is clogged.
b. Skimmer or main drain valve is closed.
c. Air leak in suction line.
d. Impeller setting is incorrect.
e. Debris on impeller vanes.
C. MOTOR 1. Motors will run hot to the touch, however, they are designed this way.Thermal
RUNS HOT overload protector will function to turn the motor off if there is an overload problem.
2. Factors which will increase operating temperature:
a. Installed in direct sun.
b. Poor ventilation.
c. Low voltage.
d. Wiring is incorrect size for load.
D. MOTOR WILL 1. Check that all power switches are on, fuse not blown, and circuit breaker
NOT TURN is not tripped.
2. Timer improperly set.
3. Impeller is against volute face.
SAVE THESE INSTRUCTIONS.
LIMITED
WARRANTY
PUMPS
PENT
AIR POOL PR
ODUCTS,
INC.
pumps are w
arr
anted to be free from def
ects in material and
w
or
kmanship.Should any of the operating parts become defective within one year from date of pur-
chase
, the
y will be replaced or repaired if def
ect is pro
ved to be the responsibility of
PENT
AIR POOL
PR
ODUCTS,
INC.
All adjustments are to be based on list prices in effect at the time of adjustment. PENTAIR POOL
PRODUCTS, INC.
will not be liable for the cost of labor or removing or replacing parts. Purchase
ag
rees to prepa
y all shipping charges to and from
PENT
AIR
POOL PRODUCTS,INC.
1620 Ha
wkins
A
v
e
., Sanf
ord, NC 27330 or 10951 West Los Angeles Ave., Moorpark, CA 93021, whichever is clos-
er or more con
v
enient.
This warranty does not cover failure in service due to fire, wreckage, freezing, willful abuse, improper repackaging
or damage incurred in shipping nor does it extend to consequential damages.
35-7000
Pr
inted in the U
.S.A.
Re
v
.
B 5/2005