Hearth and Home Technologies FI42S Log Splitter User Manual


  Open as PDF
of 22
 
1/11 33734 Rev J 7
IMPERIAL GAS LOG SET INSTALLATION INSTRUCTIONS
f. Bleed the gaslinetoextractanyairthatmayhave
been trapped inside the pipe. All connections
must betightened andchecked for leakswith a
commerciallyavailable,non-corrosiveleakcheck
solution.Besuretorinseoffthesolutionwhendone
leaktesting.DONOTUSEANOPENFLAME.Turn
offthegasaftertheleaktest.
g. Reassemble the top pan with the four screws
removedearlier,andtheburnerassemblywiththe
fourscrewsremovedearlier.
5. Grate Assembly
Thegrateassemblyshouldbepositionedontopofthetop
panandtheburnerassemblies,centeredfromlefttoright
andpulledforwardasfaraspossible.SeeFigure6.
Note: Be sure when reassembling the burner
assemblythattheburnerneckisproperlypositioned
ontheorice.
6. Place the Rock Wool, Fire Glow, Lava
Rock and Vermiculite
a. RockWool
Placeapproximately1/2”diameterpiecesofrock
woolonthetopoftheburnercoveringthefront2/3
oftheburner.Donotcovertherearrowofburner
ports.Therockwoolshouldalsobeplacedtothe
sidesoftheburneronthetoppanandunderthe
frontbarofthegrateassemblytohidetheburner.
SeeFigure7.
b. FireGlow(Fire98)
A ame colorant material that also adds to the
realismofthegasapplianceame.Afterplacing
therockwool,sprinklesomeoftheFireGlowon
thetopoftheburnerassemblyandtherockwool.
Figure 6 - Placing the Grate Assembly
c. Lava Rock
Placeonthehearthrefractoryofthereplace,allaround
thelogset.SeeFigure8.
Figure 7 - Rock Wool Placement
Figure 8 - Lava Rock
d. Vermiculite
Whenplacingthevermiculite,sprinkleitevenlyover
theareacoveredbythelavarock.
e. Itisnotnecessarytousetheentirebagoftherock
wool,theFireGlow,thelavarockorthevermiculite.
Savetheremainingportionsforlateruse.
 previous next