Hearth and Home Technologies FI42S Log Splitter User Manual


 
18 33734 Rev J 1/11
Withproperinstallationandmaintenance,yournewdecorativegasapplianceshouldprovideyearsoftrouble-freeservice.
Ifyoudoexperienceaproblem,refertothetroubleshootingguidebelow.Thisguidewillassistyouoraqualiedservice
technicianinthediagnosisofproblemsandthecorrectiveactiontobetaken.
N. Troubleshooting - “M” Series
Symptoms Possible Causes Corrective Action
1 Pilotsparks,butwillnotlight
afterrepeatedattempts.
a. Maingasshutoffvalveclosed. Makesurethattheshutoffvalvelocatedonthe
incominggaslineisopen.
b. Air in the gas line. Bleedairoutofthegasline.Retestforgasleaks
afterbleeding.
c. Pilotoriceisplugged,not
allowinggastoow.
Thisrepairrequirestoolsandsomedegreeof
experience.Callaqualiedservicetechnician.
d. Misalignedelectrode. Checksparkgap;sparkshouldbeextending
approximately1/8”tothepilothood.Adjustgapto
giveproperspark.Removehandsfromelectrode
beforeattemptingtospark.
e. No gas supply to the appliance. Checkplumbingtoensuretheappliancehasbeen
hookeduptothegassupplyline.
Thepropanetankisempty.
f. Groundwireloose. Checkthattheblackgroundwirefromtheignition
controlboxissecurelyattachedtotheground.
g. Weakbatteries. Replacewithtwonew“D”sizedbatteries.
2 Pilotlights,butwillnotstaylit. a. Weakpilotame. Pilotamemustengulftheamesensor.Cleanand/
oradjustpilotformaximumameimpingementon
amesensor.
b. Loosewireconnection Checkforloosewiresfromthepilottotheignition
controlbox.
c. Faultyamesensor. Checkthewireconnectionintotheignitioncontrol
box.Iftheconnectioniscorrect,replacesensor.
3 Pilotdoesnotsparkatall. a. Loosewireconnection. CheckforloosewiresfromOn/Offswitchtoignition
controlandremotecontrol.
b. Remotecontrol. Makesuretheswitchlocatedonthefrontofthe
remotecontrolissettothe“Remote”setting.
c. Weakbatteries. Replacewithtwonew“D”sizedbatteries.